Milk Treatments. Lecture 3 English Mustafa M. Kadhim

Size: px
Start display at page:

Download "Milk Treatments. Lecture 3 English Mustafa M. Kadhim"

Transcription

1 Milk Treatments Pasteurization Along with correct cooling, the pasteurization of milk is one of the most important processes in the treatment of milk. If carried out correctly, these processes will supply milk with the longest possible shelf life. The temperature and the pasteurization time are very important factors which must be specified precisely in relation to the quality of the milk and its shelf-life requirements, etc. The pasteurization temperature for homogenized, HTST pasteurized, regular grade milk is usually C for seconds. The pasteurization process may vary from one country to another due to different legislations. Common for all countries is that the heat treatment must guarantee the destruction of unwanted microorganisms without the product being damaged. As described in 'General Milk Treatment', one of the following procedures can be used: LTLT (Low Temperature Long Time): C for 30 minutes. HTST (High Temperature Short Time): C for second HTST: C for seconds (mainly used fr cream). One important aspect of partial homogenization concerns the heat treatment of the homogenized cream. Homogenization will have destroyed the membranes of the fat globules and exposed the fat. Therefore, this fat will have no protection against attack by the lipases which are present in the skim milk after remixing. The standardized milk must be pasteurized as quickly as possible after remixing. This does not cause any problem in the milk processing line, as remixing and pasteurization are performed rapidly and continuously in a closed process system. The problem increases where, for example, the pre standardization method is used. It then becomes necessary to design the 1

2 process in such a way that there is no possible risk of the homogenized milk or cream being mixed with unpasteurized milk or cream. If this should occur, the resulting mixture must be pasteurized immediately. Homogenization The purpose of homogenization is to disintegrate of finely distribute the fat globules in the milk in order to reduce creaming. Homogenization may be total or partial. Partial homogenization is a more economic solution as a smaller homogenizer is used. During partial homogenization the cream should have a maximum fat content of 12%, but a lower fat content, %, is normally used. Cream with a higher fat content should not be homogenized as this will result in cluster formation, mainly due to lack of material (casein) to cover the newly formed small fat droplets. A sufficiently good homogenization effect requires approximately 0.2g casein per 1g of fat. The homogenization temperature is normally C at homogenization pressure of bar. Two stage homogenization is recommended except in the production of some milks where one stage homogenization should be used. Determining the Homogenization Efficiency Homogenization must always be sufficiently efficient to prevent creaming. The homogenization of the milk can be checked by determining the homogenization index. The following may serve as an example of how to determine this index. A milk sample is kept for 48 hours at a temperature of 4-6 C. The fat content in the upper layer (1/10 of the volume) and in the lower layer (9/10 of the volume) is then determined. The difference in fat content between the upper and lower layers, expressed as a percentage of the upper layer, is referred to as the homogenization index. 2

3 An example: If the fat content in the upper layer is 3.65% and 3.35% in the lower layer, the homogenization index will be ( ) 100/3.65 = 8.2. The index for homogenized milk should be in the range 1 to 10. Production of Cream Cream sold to consumers is produced with different fat contents. The thinner type of cream is often referred to as coffee cream, but is used less and less for that purpose today and more and more for desserts and in the preparation of food. Cream with a higher fat content is usually considerably thicker. It can be whipped into a thick foam, and is therefore reffered to as 'whipping cream'. Whipping cream is used whipped or unwhipped as a dessert, for cooking, etc. Whipping Cream In addition to tasting good and keeping well, whipping cream must also have good 'whippability', i.e., the cream must be easy to whip and produce a fine cream foam with a good increase in volume. The foam must be firm and stable, and must not be disposed to syneresis. A condition for good whippability is that the cream has a sufficiently high fat content. Whipping cream with 40% fat is usually easy to whip, but the whippability decreases as the fat content drops to 30% and below. However, it is possible to produce good whipping cream with a low fat content (about 25%) by adding substances which improve the whippability, e.g., powder with a high lecithin content, made from sweet buttermilk. Air inclusion must be avoided in the manufacture of whipping cream. Air pickup leads to formation of foam and destabilization. Exposed to excessive mechanical treatment, specially shortly after having left the cooling section, the fat- globule membrances will be damaged, 3

4 resulting in fat amalgamation and formation of clusters. Creamlining takes place when roughly treated cream is stored in the package. The layer of cream will be dense and sticky. This 'homogenization effect' will greatly impair the whipping characteristics of the cream. Air is beaten into the cream when the cream is whipped. This produces a foam full of small air bubbles. The fat globules in the cream collect on the walls of these air bubbles. The mechanical agitation destorys the membrance of many fat globules and a certain amount of liquid fat is liberated. This fat makes the globules stick together. The fat globules must contain the correct proportions of liquid and crystallized fat in order to obtain a firm foam. Warm cream contains liquid fat which makes whipping impossible. Cream for whipping must therefore be stored at a low temperature (4-6 C) over a relatively long period of time in order to obtain a proper crystallization of the fat. This storage period is called ripening time. Cream is usually ripened in jacketed process tanks with scraper agitators. Heat is released during crystallization. The cream must be cooled in order to prevent a temperature increase. It should be agitated gently during ripening and cooling. Slightly lower ripening temperatures may be used in the summer, when the milk fat usually is softer than during the winter. Comprehension Exercises A. Put "T" for true and "F" for false statement. Justify your answers. 1. The pasteurization process varies in different countries due to different legislations. 2. Homogenization protects the fat droplets against heat. 3. Partial hmogenization is cheaper than tatal homogenization. 4

5 4. For more effective homogenization, the milk should contain approximately 0.2 g casein per g of fat. 5. The homogenization temperature is usually C at a pressure of bar. 6. When cream is wapped, the fat globules collect on the wall of air bubbles in it. B. Choose a, b, c, or d which best completes each item. 1. The temperature and time in the HTST process for pasteurizing milk are.... a C and 30 minutes b C and seconds c C and seconds d C and seconds 2. Homogenization of milk... creaming. a. increases. c. decreases. b. May either decrease or increase d. has no effect on. 3. When milk is homogenized, the newly formed small fat droplets will be covered with.... a. a membrane c. casein b. lactalbumin d. albumin 4. Homogenization of milk can be checked by determining the.... a. size of the fat droplets c. homogenization index b. amount of cream in the milk d. amount of casein in the milk 5. As the fat content of cream decreases, its whippability.... a. decreases c. increases b. changes d. will not change 5

6 C. Answer the following questions orally. 1. What are the pasteurization temperature and time for homogenized, HTST pasteurized, and regular-grade milk? 2. What are the three pasteurization procedures? 3. What is common for all countries with regard to milk pasteurization? 4. What is the purpose of homogenization? 5. What is whipping cream? 6. Why should cream with a high fat content not be homogenized? 7. How is the homogenization index determined? Part 3. Translation Activities A. Translate the following passage into Arabic. Market Milk Products Market milk products are liquid products made from milk and cream, intended to be used directly by consumers. This group of products includes whole milk, skim milk, standardized milk, and various types of cream. Cultured products are also included in the consumer milk products. These are made with special bacterial cultures and are dealt with separately under 'Cultured Milk Products'. All the stages of processing which have been described under 'General Milk Treatment' are, in principle, used in the processing of market milk products: Chilling Clarification and fat separation Fat standardization Deaeration Homogenization 6

7 Pasteurization In most countries, chilling, clarification, and pasteurization are compulsory stages in the processing of consumer milk products. The fat is homogenized in many countries, whilst the highest possible cream content is wanted in other countries a good 'cream line' is regarded as evidence of quality milk in these countries. Deaeration is used in certain ceses when the milk has a very high air content, and also when highly volatile, off-flavor substances are present in the product. This may occur if, for example, the cattle have eaten foods containing plants of the onion family. Processing of market milk products requires a first class raw material and correctly designed process lines if finished products of highest quality are to be attained. Gentle handling must be ensured so that the valuable constituents are not negatively influenced. B. Find the Arabic equivalents of the following items and write them in the spaces provided. 1. Booster pump Buttermilk Chilling Clarification Creaming Creamline Cultured products Dairy Displacement pump Filling machine... 7

8 11. Flow diversion valve Flow rate Flow transmitter Heat exchanger Homogenizer Low fat milk Off-flaver Pasteurizer Preheat Process line Production line Regular-grade Remix Ripening time Separator Shelf life Skim milk Syneresis Whip Whippability Whipping cream Whole milk... 8

Processing of Pasteurized Market Milk

Processing of Pasteurized Market Milk Processing of Pasteurized Market Milk Depending on legislations and regulations, the design of the process line for pasteurized market milk varies a great deal from country to country and even from dairy

More information

CREAM PRODUCTS DAIRY PROCESSING TECHNOLOGY

CREAM PRODUCTS DAIRY PROCESSING TECHNOLOGY CREAM PRODUCTS DAIRY PROCESSING TECHNOLOGY INTRODUCTION Cream products have various fat content, i.e. 10% - 48% (double cream). The importance of cream products: excellent flavor luxurious products, however

More information

Paper No.: 07 Paper Title: TECHNOLOGY OF MILK AND MILK PRODUCTS Module 07: Types of market cream

Paper No.: 07 Paper Title: TECHNOLOGY OF MILK AND MILK PRODUCTS Module 07: Types of market cream Paper No.: 07 Paper Title: TECHNOLOGY OF MILK AND MILK PRODUCTS Module 07: Types of market cream INTRODUCTION The fat contents play an important role in pricing of milk. Cream is the fat rich portion of

More information

MILK PROCESSING AND PRESERVATION

MILK PROCESSING AND PRESERVATION MILK PROCESSING AND PRESERVATION Introduction Milk processing refers to a set of methods and techniques used to transform raw milk into other forms of dairy products consumed by man. Milk processing can

More information

CONCENTRATED MILK. Dairy Processing Technology 2012/2013

CONCENTRATED MILK. Dairy Processing Technology 2012/2013 CONCENTRATED MILK Dairy Processing Technology 2012/2013 Introduction Concentrated milks are liquid milk preserves with a considerably reduced water content. Water removal is done by evaporation. Two type

More information

MILK HAS LONG BEEN A POPULAR BEVERAGE. not only for its flavor, but because of its unique nutritional package.

MILK HAS LONG BEEN A POPULAR BEVERAGE. not only for its flavor, but because of its unique nutritional package. providing high-quality protein, vitamins & other minerals HAS LONG BEEN A POPULAR BEVERAGE not only for its flavor, but because of its unique nutritional package. WHAT IS : Milk from a dairy cow is composed

More information

CODEX STANDARD FOR RAISINS CODEX STAN

CODEX STANDARD FOR RAISINS CODEX STAN CODEX STAN 67-1981 Page 1 of 5 CODEX STANDARD FOR RAISINS CODEX STAN 67-1981 1. SCOPE This standard applies to dried grapes of varieties conforming to the characteristics of Vitis vinifera L. which have

More information

Milk and Dairy Food Lecture

Milk and Dairy Food Lecture Milk and Dairy Food Lecture I. What is milk? A. 87% water B. 13% solids { fat and fat-soluble vitamins it contains and the solids not fat, include carbohydrates, protein, water-soluble vitamins and minerals.

More information

Best Quality for the Best Wines

Best Quality for the Best Wines Best Quality for the Best Wines High-quality Raw Material Only exclusively selected healthy oak is used for supplied by longstanding partners that operate controlled, sustainable forestry. Computer-aided

More information

Lecture 4. Factors affecting ripening can be physiological, physical, or biotic. Fruit maturity. Temperature.

Lecture 4. Factors affecting ripening can be physiological, physical, or biotic. Fruit maturity. Temperature. Lecture 4. Factors affecting ripening can be physiological, physical, or biotic. Physiological factors relate to fruit maturity or environmental factors, which affect the metabolism of fruit and banana.

More information

HONEY. Food and Agriculture Organization of the United Nations

HONEY. Food and Agriculture Organization of the United Nations HONEY Food and Agriculture Organization of the United Nations HONEY 1.- Honey General Information Honey has a fluid, crystallized (total or partially) consistence. Present a high viscosity and density

More information

CODEX STANDARD FOR QUICK FROZEN STRAWBERRIES 1 CODEX STAN

CODEX STANDARD FOR QUICK FROZEN STRAWBERRIES 1 CODEX STAN CODEX STAN 52 Page 1 of 6 CODEX STANDARD FOR QUICK FROZEN STRAWBERRIES 1 CODEX STAN 52-1981 1. SCOPE This standard shall apply to quick frozen strawberries (excluding quick frozen strawberry puree) of

More information

CHAPTER GELATIN. In this chapter you will learn to

CHAPTER GELATIN. In this chapter you will learn to CHAPTER GELATIN In this chapter you will learn to Demonstrate your knowledge and understanding of gelatin: Types of gelatin available How to use gelatin Factors to ensure a successful product 1. INTRODUCTION

More information

Unit F: Harvesting Fruits and Nuts. Lesson 2: Grade, Pack, Store and Transport Fruits and Nuts

Unit F: Harvesting Fruits and Nuts. Lesson 2: Grade, Pack, Store and Transport Fruits and Nuts Unit F: Harvesting Fruits and Nuts Lesson 2: Grade, Pack, Store and Transport Fruits and Nuts 1 I. After the fruit and nuts are safely harvested, they need to be graded so they can be sold at market. 2

More information

2015 Dairy Foods CDE Exam 4-H and Jr Consumer Division

2015 Dairy Foods CDE Exam 4-H and Jr Consumer Division 2015 Dairy Foods CDE Exam 4-H and Jr Consumer Division 2015, page 1 PART I OF SR. 4-H AND JR. CONSUMER CONTEST CONSUMER DAIRY PRODUCTS EXAMINATION Select the BEST or most correct answer from the available

More information

Make & Taste DAIRY. Lesson Activity. Butter (Grades 3-5) LESSON OVERVIEW: LESSON OBJECTIVES: LESSON MATERIALS NEEDED: ACADEMIC INTEGRATION

Make & Taste DAIRY. Lesson Activity. Butter (Grades 3-5) LESSON OVERVIEW: LESSON OBJECTIVES: LESSON MATERIALS NEEDED: ACADEMIC INTEGRATION Lesson Activity LESSON OVERVIEW: During this lesson, students will be introduced to both the history and science behind the process of turning heavy whipping cream (which comes from milk) into butter.

More information

THE COBURN COMPANY, INC. PO Box 147 Whitewater, WI U.S.A. Phone: Fax:

THE COBURN COMPANY, INC. PO Box 147 Whitewater, WI U.S.A. Phone: Fax: THE COBURN COMPANY, INC. PO Box 147 Whitewater, WI 53190-0147 U.S.A. Phone: 262-473-2822 Fax: 262-473-3522 800-776-7042 800-776-7044 www.coburnco.com Instruction Manual - Milky Butter Churns Coburn part

More information

The Premium Benefits of Steam Infusion UHT Treatment

The Premium Benefits of Steam Infusion UHT Treatment EDITORIAL October 2012 The Premium Benefits of Steam Infusion UHT Treatment UHT, or Ultra High Temperature, treatment uses high temperature for a short time to kill micro-organisms in a food or beverage

More information

Wine Preparation. Nate Starbard Gusmer Enterprises Davison Winery Supplies August, 2017

Wine Preparation. Nate Starbard Gusmer Enterprises Davison Winery Supplies August, 2017 Wine Preparation Nate Starbard Gusmer Enterprises Davison Winery Supplies August, 2017 Contents Intro Clarification methods Sheets, Lenticulars, Crossflow Final influences of filterability Filterability

More information

Chapter 9 BUTTER MANUFACTURE. (Butter and its principal constituents, Butter making process, Continuous flotation churn, Butter yield calculations)

Chapter 9 BUTTER MANUFACTURE. (Butter and its principal constituents, Butter making process, Continuous flotation churn, Butter yield calculations) College of Agricultural Engineering and Technology Dept. of Agricultural Processing and Food Engineering Course : Dairy and Food Engineering Chapter 9 BUTTER MANUFACTURE (Butter and its principal constituents,

More information

Name: Date: Milk Products & Eggs Course 2060

Name: Date: Milk Products & Eggs Course 2060 Name: Date: Milk Products & Eggs Course 2060 You must have credit for FOD 1010 Food Basics before starting this module. To receive credit for the course the following outcomes must be met: 1. Identify

More information

CODEX STANDARD FOR QUICK FROZEN WHOLE KERNEL CORN CODEX STAN

CODEX STANDARD FOR QUICK FROZEN WHOLE KERNEL CORN CODEX STAN CODEX STAN 32 Page of 6. SCOPE CODEX STANDARD FOR QUICK FROZEN WHOLE KERNEL CORN CODEX STAN 32-98 This standard shall apply to quick frozen whole kernel sweet corn of the species Zea mays L. convar. saccharata

More information

IMPORTANT SAFEGUARDS. 3. To protect against fire, electric shock and injury to persons do not immerse cord, plug or unit in water or other liquid.

IMPORTANT SAFEGUARDS. 3. To protect against fire, electric shock and injury to persons do not immerse cord, plug or unit in water or other liquid. IMPORTANT SAFEGUARDS When using electrical appliances, basic precautions should always be followed, including the following: 1. Read all instructions. 2. Make sure that your outlet voltage corresponds

More information

TECHNICAL INFORMATION SHEET: MAGICOL AK ISINGLASS FININGS

TECHNICAL INFORMATION SHEET: MAGICOL AK ISINGLASS FININGS TECHNICAL INFORMATION SHEET: MAGICOL AK ISINGLASS FININGS PRODUCT NAME: MAGICOL AK PRODUCT CODE: MLAK COMMODITY CODE: 35030080 PACKAGING: 1 KG GUIDELINES FOR USE Check that the product is within its shelf

More information

Recommended Resources: The following resources may be useful in teaching

Recommended Resources: The following resources may be useful in teaching Unit F: Harvesting Fruits and Nuts Lesson 2: Grade, Pack, Store and Transport Fruits and Nuts Student Learning Objectives: Instruction in this lesson should result in students achieving the following objectives:

More information

Draught System Troubleshooting & Reference Manual

Draught System Troubleshooting & Reference Manual Draught System Troubleshooting & Reference Manual BeerTech.ca Parts Of A Basic System Beer Line Keg Coupler High Pressure Gauge Regulator Low Pressure Gauge Regulator Coupling Nut Drum Valve Set Screw

More information

Dairy foods provide many valuable nutrients. Dairy foods come in a variety of flavors and forms. They are an important part of a healthful diet.

Dairy foods provide many valuable nutrients. Dairy foods come in a variety of flavors and forms. They are an important part of a healthful diet. Dairy foods provide many valuable nutrients. Dairy foods come in a variety of flavors and forms. They are an important part of a healthful diet. 1 Looking at Dairy Dairy cows were brought to the American

More information

Science & Technology of Jams and Jellies. Dr. Malcolm Bourne

Science & Technology of Jams and Jellies. Dr. Malcolm Bourne Science & Technology of Jams and Jellies Dr. Malcolm Bourne Introduction Jams, Jellies, Marmalades, Conserves and Fruit Butters are made by boiling together fruit and sugar to give a high solids product.

More information

Factors affecting finished products

Factors affecting finished products Factors affecting finished products See separate word document on factors affecting finished product as shown on next slide Too little Less moist Product become stale quicker Less flavour and colour TOO

More information

Beef. Multiple Choice. 1. About 75% of muscle tissue, or meat is (a) protein. (b) water. (c) fat. (d) collagen.

Beef. Multiple Choice. 1. About 75% of muscle tissue, or meat is (a) protein. (b) water. (c) fat. (d) collagen. Beef Multiple Choice 1. About 75% of muscle tissue, or meat is (a) protein. (b) water. (c) fat. (d) collagen. 2. A federal inspection stamp on a cut of meat indicates that the cut was found to be (a) properly

More information

TURBOMIXERS AND PREMIXERS. VERTIMIX TURBOMIXER GTM SERIES TURBOMIXER GTM TANK-LESS SERIES TURBOMIXER GMG SERIES PREMIXER PCG SERIES

TURBOMIXERS AND PREMIXERS.   VERTIMIX TURBOMIXER GTM SERIES TURBOMIXER GTM TANK-LESS SERIES TURBOMIXER GMG SERIES PREMIXER PCG SERIES TURBOMIXER GTM SERIES TURBOMIXERS AND PREMIXERS TURBOMIXER GTM TANK-LESS SERIES TURBOMIXER GMG SERIES VERTIMIX TECHNOLOGY PREMIXER PCG SERIES www.gorreri.com TECHNOLOGIES FOR CONTINUOUS MIXING SPEED RELIABILITY

More information

Tomato Product Cutting Tips

Tomato Product Cutting Tips Tomato Product Cutting Tips Tomato Product Cutting Tips Know your customer and the application of the products being shown. Confirm the products will work for the application. Listen to the customer regarding

More information

It is the process of heating every particle of milk or milk products

It is the process of heating every particle of milk or milk products Class 11: Processing of milk-cooling-pasteurization-definition-various methods-low Temperature Long Time, High Temperature Short Time and Ultra High Temperatureadvantages and disadvantages. Thermal processing

More information

PERFORMANCE CRITERIA To be competent you must achieve the following:

PERFORMANCE CRITERIA To be competent you must achieve the following: U10001: Unit Descriptor: This unit describes the competence required to effectively prepare and bake food The unit describes the essential abilities of: Effectively maintaining safety and hygiene requirements

More information

HOW TO USE AND TAKE CARE OF THE HAGLÖF INCREMENT BORER

HOW TO USE AND TAKE CARE OF THE HAGLÖF INCREMENT BORER HOW TO USE AND TAKE CARE OF THE HAGLÖF INCREMENT BORER HOW TO USE THE HAGLÖF INCREMENT BORER A. Unscrew the extractor from the handle. B. Remove the borer auger (bit) from the handle along with the extractor

More information

Japan, Chocolate, Vegetable fats, Chocolate standards

Japan, Chocolate, Vegetable fats, Chocolate standards 1 SCI LECTURE PAPERS SERIES THE VIEW FROM JAPAN I Nakamura 1 and H Kida 2 1. Fuji Oil Europe, Kuhlmannlaan 36, B-9042 Gent, Belgium 2. Fuji Oil Co., Ltd., 1 Sumiyoshi-cho, Izumisano-shi, Osaka, Japan 2003

More information

Pasteurization of Milk Booklet No.281 Dairy Management & Milk Products: DMMPS - 11

Pasteurization of Milk Booklet No.281 Dairy Management & Milk Products: DMMPS - 11 Contents Preface I. Introduction Pasteurization of Milk Booklet No.281 Dairy Management & Milk Products: DMMPS - 11 II. Advantages of Pasteurization III. Temperature & Time Combination IV. Methods of Pasteurization

More information

Virtual Cheesemaking Tour

Virtual Cheesemaking Tour Virtual Cheesemaking Tour The Milk Arrives Each morning that cheese is made, the fresh milk arrives straight from the dairy. Vella Cheese has used milk from nearby Merten s Dairy in Sonoma for more than

More information

SOLUTIONS IN BRIX MEASUREMENT

SOLUTIONS IN BRIX MEASUREMENT SOLUTIONS IN BRIX MEASUREMENT APPLICATIONS OF DT301-TOUCHÉ IN SUGAR & ALCOHOL INDUSTRIES I ABSTRACT: Based on the success of the product, concentration and density transmitter SMAR, DT301- Touché, close

More information

Proper storage of food

Proper storage of food 1 Proper storage of food Store foods correctly: In the correct place, e.g. store raw and cooked foods separately in the refrigerator At the correct temperature, e.g. leftover foods should be kept in the

More information

MODELS 1315 & 1315-S La Pavoni CLUB COMBO

MODELS 1315 & 1315-S La Pavoni CLUB COMBO IMPORTANT WARNINGS MODELS 1315 & 1315-S La Pavoni CLUB COMBO DUET Never operate your espresso machine without water in the tank. This may cause premature pump failure. Do not allow the power cord to come

More information

RAW MILK QUALITY - MILK FLAVOR

RAW MILK QUALITY - MILK FLAVOR Dairy Day 1993 H.A. Roberts RAW MILK QUALITY - MILK FLAVOR Summary Flavor control in market milk begins on the farm and continues through the processing plant and into the home of the consumer. Flavor

More information

TREATED ARTICLES NEW GUIDANCE AND REGULATION BIOCIDE SYMPOSIUM 2015 LJUBLJANA MAY DR. PIET BLANCQUAERT

TREATED ARTICLES NEW GUIDANCE AND REGULATION BIOCIDE SYMPOSIUM 2015 LJUBLJANA MAY DR. PIET BLANCQUAERT TREATED ARTICLES NEW GUIDANCE AND REGULATION BIOCIDE SYMPOSIUM 2015 LJUBLJANA 11-12 MAY DR. PIET BLANCQUAERT CONTENT 2 The BPR and its amendment Updated guidance Biocidal property and (primary) biocidal

More information

STANDARD FOR QUICK FROZEN BLUEBERRIES CODEX STAN

STANDARD FOR QUICK FROZEN BLUEBERRIES CODEX STAN CODEX STAN 03-98 Page of 6 STANDARD FOR QUICK FROZEN BLUEBERRIES CODEX STAN 03-98. SCOPE This standard shall apply to quick frozen blueberries of the species Vaccinium corymbosum L., Vaccinium angustifolium

More information

PURCHASE OF MILK AND PRODUCTION OF MILK PRODUCTS,

PURCHASE OF MILK AND PRODUCTION OF MILK PRODUCTS, PURCHASE OF MILK AND PRODUCTION OF MILK PRODUCTS, 2007 2011 Helina Uku Statistics Estonia Milk is one of the main food products and it is important that the need for milk is covered by domestic milk production.

More information

INDEPENDENT, TRADITIONAL, AND INNOVATIVE Flottweg Separators for Craft Breweries

INDEPENDENT, TRADITIONAL, AND INNOVATIVE Flottweg Separators for Craft Breweries INDEPENDENT, TRADITIONAL, AND INNOVATIVE Flottweg Separators for Craft Breweries LATEST TECHNOLOGY MEETS TRADITION Separators for Craft Brewers Tradition and the modern are no contradiction at Flottweg.

More information

Ganimede. simply a better wine...

Ganimede. simply a better wine... Ganimede simply a better wine... Il fermantatore brevettato - Le fermenteur breveté - El fermentador patentado - The patented fermenter - Patentierte Gärbehälte Il fermantatore brevettato - Le fermenteur

More information

Other cheeses. by Blendhub. Stabilizers. Mediterranean style cheese (Feta type) Mascarpone cheese Cheese portions

Other cheeses. by Blendhub. Stabilizers. Mediterranean style cheese (Feta type) Mascarpone cheese Cheese portions by Blendhub Stabilizers Other cheeses Mediterranean style cheese (Feta type) Mascarpone cheese Cheese portions Blendhub provides solutions for special cheeses, such as Mediterranean style cheese (Feta

More information

LESS FAT. FULL FLAVOR. ICE CREAM GETS A MAKEOVER WITH THE HELP OF SPX EQUIPMENT.

LESS FAT. FULL FLAVOR. ICE CREAM GETS A MAKEOVER WITH THE HELP OF SPX EQUIPMENT. ICE CREAM GETS A MAKEOVER WITH THE HELP OF SPX EQUIPMENT. SPX IS PLAYING A ROLE IN SUPPORTING AND SPURRING ADVANCES IN ICE CREAM PRODUCTION. Cooler Ice Cream Production From Tel Aviv to Tokyo, it seems

More information

How to fine-tune your wine

How to fine-tune your wine How to fine-tune your wine Fining agents help remove undesirable elements or compounds to improve the quality of wine. Fining is not just used in wines for bottle preparation, in some cases there are more

More information

COMMISSION IMPLEMENTING REGULATION (EU) No /.. of XXX. on the traceability requirements for sprouts and seeds intended for the production of sprouts

COMMISSION IMPLEMENTING REGULATION (EU) No /.. of XXX. on the traceability requirements for sprouts and seeds intended for the production of sprouts EUROPEAN COMMISSION Brussels, XXX SANCO/10030/2012r7 [ ](2012) XXX draft - COMMISSION IMPLEMENTING REGULATION (EU) No /.. of XXX on the traceability requirements for sprouts and seeds intended for the

More information

Instructor: Stephen L. Love Aberdeen R & E Center 1693 S 2700 W Aberdeen, ID Phone: Fax:

Instructor: Stephen L. Love Aberdeen R & E Center 1693 S 2700 W Aberdeen, ID Phone: Fax: Vegetable Crops PLSC 451/551 Lesson 7, Harvest, Handling, Packing Instructor: Stephen L. Love Aberdeen R & E Center 1693 S 2700 W Aberdeen, ID 83210 Phone: 397-4181 Fax: 397-4311 Email: slove@uidaho.edu

More information

Notes on acid adjustments:

Notes on acid adjustments: Notes on acid adjustments: In general, acidity levels in 2018 were lower than normal. Grape acidity is critical for the winemaking process, as well as the quality of the wine. There are 2 common ways to

More information

EFFECT OF TOMATO GENETIC VARIATION ON LYE PEELING EFFICACY TOMATO SOLUTIONS JIM AND ADAM DICK SUMMARY

EFFECT OF TOMATO GENETIC VARIATION ON LYE PEELING EFFICACY TOMATO SOLUTIONS JIM AND ADAM DICK SUMMARY EFFECT OF TOMATO GENETIC VARIATION ON LYE PEELING EFFICACY TOMATO SOLUTIONS JIM AND ADAM DICK 2013 SUMMARY Several breeding lines and hybrids were peeled in an 18% lye solution using an exposure time of

More information

Knowledge booklet- Chicken products

Knowledge booklet- Chicken products YEAR 9 FOOD PREPARATION At the end of this unit you will have an assessment. 50% = The quality of your dishes cooked, with regard to hygiene and safety. 50% = The information you have learnt. Knowledge

More information

Canning and Preserving the Harvest FALL 2018

Canning and Preserving the Harvest FALL 2018 Canning and Preserving the Harvest FALL 2018 Course Objectives Demonstrate how to safely and properly extend the shelf life of foods. Demonstrate use of various preservation methods including canning,

More information

SRI VENKATESWARA UNIVERSITY

SRI VENKATESWARA UNIVERSITY SRI VENKATESWARA UNIVERSITY DAIRY SCIENCE III YEAR - SEMESTER- VI ELECTIVE - A TITLE: TECHNOLOGY OF DAIRY PRODUCTS-I PAPER-7 THEORY 4 Credits 60 Lecture Hours Maximum Marks:100 UNIT-I. a) Reception of

More information

Variations in the Test of Separator Cream.

Variations in the Test of Separator Cream. Variations in the Test of Separator Cream. One of the greatest problems that has presented itself to the creamery patrons and managers of the West-Central states for the past few years is that of the cause

More information

Jellies, Jams & Preserves

Jellies, Jams & Preserves Jellies, Jams & Preserves Peggy Van Laanen Professor and Extension Nutrition Specialist; The Texas A&M University System pg 1 Many people prepare home-preserved jellies, jams, preserves and fruit spreads

More information

Acta Chimica and Pharmaceutica Indica

Acta Chimica and Pharmaceutica Indica Acta Chimica and Pharmaceutica Indica Research Vol 7 Issue 2 Oxygen Removal from the White Wine in Winery VladimirBales *, DominikFurman, Pavel Timar and Milos Sevcik 2 Faculty of Chemical and Food Technology,

More information

COMPARATIVE ANALYZE BETWEEN CHEESES OBTAINED FROM UNPASTEURIZED AND PASTEURIZED MILK. Abstract. Introduction

COMPARATIVE ANALYZE BETWEEN CHEESES OBTAINED FROM UNPASTEURIZED AND PASTEURIZED MILK. Abstract. Introduction C. Roibu, et all. Journal of Agroalimentary Processes and Technologies, Volume XIII, No.1 (2007), 35-40 Full Paper Food Technology and Processing COMPARATIVE ANALYZE BETWEEN CHEESES OBTAINED FROM UNPASTEURIZED

More information

Acid Flavors (Indicated by a sour smell and taste)

Acid Flavors (Indicated by a sour smell and taste) DEFECTS IN FLAVOR Acid Flavors (Indicated by a sour smell and taste) Over development of acidity during the ripening process due to: 1. Ripening the milk to much before adding the rennet 2. The use of

More information

Post-Harvest Storage of Pulses

Post-Harvest Storage of Pulses Post-Harvest Storage of Pulses Bruce Barker, PAg Tips For Safe Storage Good management of pea, lentil, faba bean, chickpea, bean, and soybean in storage will help maintain the value of your crop. Moisture

More information

Ozone experimentation one the shelf life of various fruits

Ozone experimentation one the shelf life of various fruits Ozone experimentation one the shelf life of various fruits Abstract Earth Safe Ozone will investigate the effects of ozone on fruit storage at room temperature. Ozone has been shown to reduce mold and

More information

CODEX STANDARD FOR CANNED SWEET CORN 1 CODEX STAN For the purposes of this standard, canned sweet corn does not include corn-on-the-cob.

CODEX STANDARD FOR CANNED SWEET CORN 1 CODEX STAN For the purposes of this standard, canned sweet corn does not include corn-on-the-cob. CODEX STAN 8 Page of 6. SCOPE CODEX STANDARD FOR CANNED SWEET CORN CODEX STAN 8-98 For the purposes of this standard, canned sweet corn does not include corn-on-the-cob. 2. DESCRIPTION 2. Product Definition

More information

COURSE FOD 3040: YEAST PRODUCTS

COURSE FOD 3040: YEAST PRODUCTS Name: Due Date: COURSE FOD 3040: YEAST PRODUCTS Prerequisite: FOD1010: Food Basics Description: Students further their skills in the handling of yeast dough through the preparation of a variety of yeast

More information

DRAFT TANZANIA STANDARD

DRAFT TANZANIA STANDARD TBS/AFDC 13 (5361) P3 Rev TZS 1245:2010 ICS: 67.160 DRAFT TANZANIA STANDARD Draught beer Specification TANZANIA BUREAU OF STAND TBS 2010 Second Edition 2010 TANZANIA STANDARD TBS/AFDC 13(5361) P3 / Rev.

More information

Other cheeses INGREDIENTS. Stabilizers. Mediterranean style cheese (Feta type) Mascarpone cheese Cheese portions

Other cheeses INGREDIENTS. Stabilizers. Mediterranean style cheese (Feta type) Mascarpone cheese Cheese portions INGREDIENTS Stabilizers Other cheeses Mediterranean style cheese (Feta type) Mascarpone cheese Cheese portions Premium Ingredients provides solutions for special cheeses, such as Mediterranean style cheese

More information

Equipment. Quantity. Storage. Make sure workstations, cutting boards, and utensils are clean and sanitized

Equipment. Quantity. Storage. Make sure workstations, cutting boards, and utensils are clean and sanitized Equipment Make sure workstations, cutting boards, and utensils are clean and sanitized Quantity Only remove as much food from the cooler as you can prep in a short period of time Storage Return prepped

More information

Food Science and Technology Notes

Food Science and Technology Notes Food Science and Technology Notes Extension Division Deportment of Food ScienceandTechnology Virginia Polytechnic Institute Blacksburg, Virginia SEP - - 197~ HOMEMADE CULTURED MILK PRODUCTS by P. M. Large,

More information

STANDARD FOR CANNED CHESTNUTS AND CANNED CHESTNUT PUREE CODEX STAN Adopted in Amendment: 2015.

STANDARD FOR CANNED CHESTNUTS AND CANNED CHESTNUT PUREE CODEX STAN Adopted in Amendment: 2015. STANDARD FOR CANNED CHESTNUTS AND CANNED CHESTNUT PUREE CODEX STAN 145-1985 Adopted in 1985. Amendment: 2015. CODEX STAN 145-1985 2 1. DESCRIPTION 1.1 Product Definition 1.1.1 Canned chestnuts is the product

More information

Post-Harvest-Multiple Choice Questions

Post-Harvest-Multiple Choice Questions Post-Harvest-Multiple Choice Questions 1. Chilling injuries arising from the exposure of the products to a temperature a. above the normal physiological range b. below the normal physiological range c.under

More information

Buying Filberts On a Sample Basis

Buying Filberts On a Sample Basis E 55 m ^7q Buying Filberts On a Sample Basis Special Report 279 September 1969 Cooperative Extension Service c, 789/0 ite IP") 0, i mi 1910 S R e, `g,,ttsoliktill:torvti EARs srin ITQ, E,6

More information

Bread Troubleshooting Guide

Bread Troubleshooting Guide Holes in Bread weakens the dough and undermixing Dough forms a crust, trapping gas. Adjust proofer to proper humidity. Moulder Rollers in Poor Condition Trapped gas in dough causes holes. Check and repair

More information

QUALITY DESCRIPTOR / REPRESENTATIONS GUIDELINES FOR THE

QUALITY DESCRIPTOR / REPRESENTATIONS GUIDELINES FOR THE QUALITY DESCRIPTOR / REPRESENTATIONS GUIDELINES FOR THE AUSTRALIAN FRUIT JUICE INDUSTRY Adopted 30 September 2005 Reviewed 12 January 2007 CODE OF PRACTICE QUALITY DESCRIPTOR/REPRESENTATIONS GUIDELINES

More information

FOD 2180 VEGETABLES and FRUITS

FOD 2180 VEGETABLES and FRUITS Name: Date: Prerequisite: Food Basics (FOD1010) Course Mark Criteria: Theory and Worksheets (20%) Test (30%) Lab Mark/Initials (50%) FOD 2180 VEGETABLES and FRUITS Description: Students learn about the

More information

BETTER BUTTER II. Robert L. Bradley

BETTER BUTTER II. Robert L. Bradley BETTER BUTTER II Robert L. Bradley Better Butter II Robert L. Bradley Professor Emeritus University of Wisconsin Department of Food Science 2018 Reviewed by: Marianne Smukowski, Thomas Szalkucki Edited

More information

Thermal Hydraulic Analysis of 49-2 Swimming Pool Reactor with a. Passive Siphon Breaker

Thermal Hydraulic Analysis of 49-2 Swimming Pool Reactor with a. Passive Siphon Breaker Thermal Hydraulic Analysis of 49-2 Swimming Pool Reactor with a Passive Siphon Breaker Zhiting Yue 1, Songtao Ji 1 1) China Institute of Atomic Energy(CIAE), Beijing 102413, China Corresponding author:

More information

Introduction to Measurement and Error Analysis: Measuring the Density of a Solution

Introduction to Measurement and Error Analysis: Measuring the Density of a Solution Introduction to Measurement and Error Analysis: Measuring the Density of a Solution Introduction: Most of us are familiar with the refreshing soft drink Coca-Cola, commonly known as Coke. The formula for

More information

EDICT ± OF GOVERNMENT

EDICT ± OF GOVERNMENT EDICT ± OF GOVERNMENT Inordertopromotepubliceducationandpublicsafety,equal justiceforal,abeterinformedcitizenry,theruleoflaw,world tradeandworldpeace,thislegaldocumentisherebymade availableonanoncommercialbasis,asitistherightofal

More information

Test sheet preparation of pulps and filtrates from deinking processes

Test sheet preparation of pulps and filtrates from deinking processes December 2014 6 Pages Introduction Pulp made of paper for recycling typically contains printing inks which influence its optical properties. Cleaning and flotation remove small impurities and printing

More information

Brewhouse technology

Brewhouse technology Brewhouse technology For Beer with Character Brewhouse technology The best quality wort for the best quality beer The brewhouse is the heart of every brewery and therefore crucial to the quality of the

More information

Strainers In-Line and Angle

Strainers In-Line and Angle Design Specifications DSSTRAINERS Revision 02 Strainers In-Line and Angle Description Strainers are installed in pipe lines ahead of meters, pumps, valves, etc., to protect such equipment against intrusion

More information

PORTABLE ESPRESSO MACHINE. Compatible Ground Coffee only. Designed by

PORTABLE ESPRESSO MACHINE. Compatible Ground Coffee only. Designed by GR PORTABLE ESPRESSO MACHINE Compatible Ground Coffee only Designed by Dear Customer, Thank you for having chosen our product and for your confidence in our company. We have devoted all our knowledge,

More information

COFFEE MAKER INSTRUCTION MANUAL CM4682-V

COFFEE MAKER INSTRUCTION MANUAL CM4682-V COFFEE MAKER INSTRUCTION MANUAL CM4682-V IMPORTANT SAFEGUARDS Before using the electrical appliance, the following basic precautions should always be followed including the following: 1. Read all instructions.

More information

Judging Canned Fruits and Fruit Juices

Judging Canned Fruits and Fruit Juices Judging Canned Fruits and Fruit Juices Headspace for fruits should be ½ inch. Apple juice, grape juice and fruit purees use ¼ inch headspace. Canned fruit should meet all of the general characteristics

More information

Beer. in a Box. The future for draft beer distribution

Beer. in a Box. The future for draft beer distribution Beer in a Box The future for draft beer distribution Carbonate Solutions Ltd is a UK Technology company specialising in carbonating drinks at the point of dispense. Incorporating 20 years research and

More information

CODEX STANDARD FOR CANNED PLUMS 1 CODEX STAN

CODEX STANDARD FOR CANNED PLUMS 1 CODEX STAN CODEX STAN 59 Page 1 of 9 1. DESCRIPTION 1.1 Product Definition CODEX STANDARD FOR CANNED PLUMS 1 CODEX STAN 59-1981 Canned plums is the product (a) prepared from clean, substantially sound, whole or halved

More information

During this November trip 9 wineries have been visited 5 wineries had been audited in March and 4 were new to join the program.

During this November trip 9 wineries have been visited 5 wineries had been audited in March and 4 were new to join the program. INTRODUCTION During this November trip 9 wineries have been visited 5 wineries had been audited in March and 4 were new to join the program. Some wineries are already producing sparkling wines and some

More information

YOUR PUMP SOLUTION FOOD INDUSTRY

YOUR PUMP SOLUTION FOOD INDUSTRY YOUR PUMP FOOD INDUSTRY PUMP S FOR THE FOOD INDUSTRY 2 PUMP S FOR THE FOOD INDUSTRY 3 TO MAXIMIZE CLEANLINESS AND QUALITY. MODULAR PUMP SYSTEM 8 PRODUCT GROUPS OVER 27 S CUSTOMER-SPECIFIC S y Uniquely

More information

Beer Preparation for Packaging. Jamie Ramshaw M.Brew Simpsons Malt

Beer Preparation for Packaging. Jamie Ramshaw M.Brew Simpsons Malt Beer Preparation for Packaging Jamie Ramshaw M.Brew Simpsons Malt Conditioning Cask Processed Beer Preparation Conditioning Haze and Clarity Stabilisation Conditioning Aims Flavour development Development

More information

Make & Taste Dairy. Whipped Cream (Grades 3-5) Lesson Plan LESSON OVERVIEW: LESSON OBJECTIVES:

Make & Taste Dairy. Whipped Cream (Grades 3-5) Lesson Plan LESSON OVERVIEW: LESSON OBJECTIVES: Lesson Plan LESSON OVERVIEW: During this lesson, students will be introduced to both the history and science behind the process of whipping heavy cream into a delicious topping. Participants will make

More information

CODEX STANDARD FOR CANNED APRICOTS CODEX STAN

CODEX STANDARD FOR CANNED APRICOTS CODEX STAN CODEX STAN 129 Page 1 of 9 CODEX STANDARD FOR CANNED APRICOTS CODEX STAN 129-1981 1. DESCRIPTION 1.1 Product Definition Canned apricots is the product (a) prepared from stemmed, fresh or frozen or previously

More information

CODEX STANDARD FOR PINEAPPLES (CODEX STAN )

CODEX STANDARD FOR PINEAPPLES (CODEX STAN ) CODEX STAN 182 Page 1 of 5 1. DEFINITION OF PRODUCE CODEX STANDARD FOR PINEAPPLES (CODEX STAN 182-1993) This Standard applies to commercial varieties of pineapples grown from Ananas comosus (L.) Merr.,

More information

ENARTIS NEWS UTILIZING TANNINS AND POLYSACCHARIDES TO POLISH AND FINISH WINES BEFORE BOTTLING

ENARTIS NEWS UTILIZING TANNINS AND POLYSACCHARIDES TO POLISH AND FINISH WINES BEFORE BOTTLING ENARTIS NEWS UTILIZING TANNINS AND POLYSACCHARIDES TO POLISH AND FINISH WINES BEFORE BOTTLING A wine which has oxidized, reduced, herbaceous, bitter, astringent or burning qualities is generally considered

More information

Topic: Preventing Cross-Contamination

Topic: Preventing Cross-Contamination Topic: Preventing Cross-Contamination WHAT IS Back to Basics? Four food safety training activities - to help train your frontline employees. Customize these modules by reviewing your own policies and applicable

More information

Foodborne Illness Can Cause More than a Stomach Ache!

Foodborne Illness Can Cause More than a Stomach Ache! Foodborne Illness Can Cause More than a Stomach Ache! Signs and symptoms Upset stomach Fever Diarrhea Vomiting Dehydration (sometimes severe) Don t count on these to test for food safety! Sight Smell Taste

More information

Quiz. Q Does chocolate milk come from brown cows? A No. All cows, regardless of their colours, produce white milk.

Quiz. Q Does chocolate milk come from brown cows? A No. All cows, regardless of their colours, produce white milk. 1 Q Does chocolate milk come from brown cows? A No. All cows, regardless of their colours, produce white milk. 2 Q How many legs do cows have? A 4! Like all ruminants. Kids 3 Q Do cows sleep in stables

More information

OPERATING INSTRUCTIONS FOR YOUR SAFETY CAREFULLY READ THE OPERATING INSTRUCTIONS. FOR HOUSEHOLD USE ONLY

OPERATING INSTRUCTIONS FOR YOUR SAFETY CAREFULLY READ THE OPERATING INSTRUCTIONS. FOR HOUSEHOLD USE ONLY OPERATING INSTRUCTIONS FOR YOUR SAFETY CAREFULLY READ THE OPERATING INSTRUCTIONS. FOR HOUSEHOLD USE ONLY 2 Opening Congratulations on choosing this high quality espresso machine and thank you for your

More information

EC Home Canning of Fruits and Vegetables

EC Home Canning of Fruits and Vegetables University of Nebraska - Lincoln DigitalCommons@University of Nebraska - Lincoln Historical Materials from University of Nebraska- Lincoln Extension Extension 1970 EC70-925 Home Canning of Fruits and Vegetables

More information