TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner HC4A3

Transcription

1 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner HC4A3 DANGER, WARNING, CAUTION, and NOTE The signal words DANGER, WARNING, CAUTION, and NOTE are used to identify levels of hazard seriousness. The signal word DANGER is only used on product labels to signify an immediate hazard. The signal words WARNING, CAUTION, and NOTE will be used on product labels and throughout this manual and other manuals that may apply to the product. DANGER Immediate hazards which will result in severe personal injury or death. WARNING Hazards or unsafe practices which could result in severe personal injury or death. CAUTION Hazards or unsafe practices which may result in minor personal injury or product or property damage. NOTE Used to highlight suggestions which will result in enhanced installation, reliability, or operation. Safety Labeling and Signal Words Signal Words in Manuals The signal word WARNING is used throughout this manual in the following manner: WARNING! WARNING The signal word CAUTION is used throughout this manual in the following manner:! CAUTION Signal Words on Product Labeling Signal words are used in combination with colors and/or pictures on product labels. TABLE OF CONTENTS Model Number Identification... 2 Wiring Diagrams Charging Chart... 5 Tech Labels Cooling Multiplying Factors Parts Drawing Parts List Single Phase Parts List Three Phase MODELS Single Phase HC4A318AKA HC4A324AKA HC4A330AKA HC4A336AKA HC4A348AKA HC4A360AKA Three Phase HC4A336AHA HC4A336ALA HC4A348AHA HC4A348ALA HC4A360AHA HC4A360ALA! WARNING DEATH, PERSONAL INJURY, AND/OR PROPERTY DAMAGE HAZARD Failure to carefully read and follow this warning could result in equipment malfunction, property damage, personal injury and/or death. Installation or repairs made by unqualified persons could result in equipment malfunction, property damage, personal injury and/or death. The information contained in this manual is intended for use by a qualified service technician familiar with safety procedures and equipped with the proper tools and test instruments. Installation must conform with local building codes and with the National Electrical Code NFPA70 current edition or Canadian Electrical Code Part 1 CSA C Dec 2010

2 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 OUTDOOR UNIT MODEL NUMBER IDENTIFICATION GUIDE Digit Position: 1, , Example Part Number: HC 4 A 3 18 A K A Horizontal Condenser UNIT 4 = R 410A REFRIGERANT A = Air Conditioner H = Heat Pump TYPE 3 = 13 SEER 4 = 14 SEER NOMINAL EFFICIENCY 18 = 18,000 BTUH = 1 1/2 tons 24 = 24,000 BTUH = 2 tons 30 = 30,000 BTUH = 2 1/2 tons 36 = 36,000 BTUH = 3 tons 42 = 42,000 BTUH = 3 1/2 tons 48 = 48,000 BTUH = 4 tons 60 = 60,000 BTUH = 5 tons NOMINAL CAPACITY A = Standard Grille FEATURES K = 208/ H = 208/ L = Sales Code Engineering Revision Extra Digit Extra Digit VOLTAGE ACCESSORIES PART NUMBER IDENTIFICATION GUIDE Digit Position: , 7 8, 9 10, 11 Example Part Number: N A S A C H N = Non Branded A = Accessory BRANDING PRODUCT GROUP S = Split System (AC & HP) A = Original B = 2nd Generation 0 = Generic or Not Applicable 2 = R 22 KIT USAGE MAJOR SERIES 4 = R 410A REFRIGERANT Product Identifier Number Package Quantity Type of Kit (Example: CH = Crankcase Heater)

3 /230 SINGLE PHASE Model Sizes: 18, 24, 30, 36, 48, 60

4 /460 THREE PHASE Model Sizes: 36, 48, 60

5 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 Measured Liquid Pressure (psig) R 410A CHARGING CHART Rating Plate (required) Subcooling Temperature F ( C) F ( C) F ( C) F ( C) F ( C) F ( C) F ( C) R 410A Required Liquid Line Temperature F ( C)

6 COOLING 18 Size with EDD4X18B Indoor Cooling Outdoor Ambient Temperature Degrees F, Dry Bulb Entering Indoor Temperature Degrees F, Dry Bulb CFM MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR COOLING 24 Size with EDD4X24B Indoor Cooling Outdoor Ambient Temperature Degrees F, Dry Bulb Entering Indoor Temperature Degrees F, Dry Bulb CFM MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR See Notes following tables.

7 COOLING 30 Size with EDD4X30B Indoor Cooling Outdoor Ambient Temperature Degrees F, Dry Bulb Entering Indoor Temperature Degrees F, Dry Bulb CFM MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR COOLING 36 Size with EDD4X42J Indoor Cooling Outdoor Ambient Temperature Degrees F, Dry Bulb Entering Indoor Temperature Degrees F, Dry Bulb CFM MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR See Notes following tables.

8 COOLING 48 Size with EDD4X48J Indoor Cooling Outdoor Ambient Temperature Degrees F, Dry Bulb Entering Indoor Temperature Degrees F, Dry Bulb CFM MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR COOLING 60 Size with EDD4X60L Indoor Cooling Outdoor Ambient Temperature Degrees F, Dry Bulb Entering Indoor Temperature Degrees F, Dry Bulb CFM MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR MBh S/T AMPS* HI PR LO PR See Notes following tables.

9 Total capacities are net (I.D. blower heat subtracted) system capacities based on 25 line set. If additional tubing length and/or indoor unit is located above outdoor unit, a slight variation in capacity may occur. At TVA rating indoor condition (75 F db, 63 F wb), all other indoor air temperatures are at 80 F db If additional tubing length and/or indoor unit is located above outdoor unit, a slight variation in capacity may occur. ^ System amps are total of indoor and outdoor amps. Chart data is for 80 F indoor dry bulb. For indoor db temperatures other than 80 F, measure Indoor db and Indoor CFM, and plug these into the formula below. Measure outdoor db and indoor wet bulb, apply these to the chart above, find MBh and S/T, and plug these into the formula below. (Note: if indoor db is the only thing changing, total capacity, MBh, stays the same.) ( ) Sensible Capacity at Indoor db LOWER than 80 F = ( MBh x S/T ) ( 80 Indoor db ) x 835 x Indoor CFM 1000 ( ) ( Indoor db 80 ) x 835 x Indoor CFM Sensible Capacity at Indoor db HIGHER than 80 F = ( MBh x S/T )

10 COOLING Multiplying Factors for other Indoor Combinations HC4A318 >ED*4X18B** EN(A,D)4X19*17** ENH4X24*17** *9MPV EHD4X24A** *8MV* ** EN(A,D)4X24*14** *8MV* ** ENH4X24*17** *9MVX EHD4X24A** *8MV* ** EN(A,D)4X24*14** *8MX* ** ENH4X24*17** *9MVX EHD4X24A** *8MX* ** EN(A,D)4X24*14** ENH4X24*17** NOMV106D12* EHD4X24A** NOMV106D12* EN(A,D)4X24*17** *8MV* ** ENH4X24*17** OLV098A12A EHD4X24A** OLV098A12A EN(A,D)4X24*17** NOMV106D12* ENH4X24*17** OMV098J12A EHD4X24A** OMV098J12A EN(A,D)4X24*17** OLV098A12A ENH4X24*17** EN(A,D)4X18*14** *8MV* ** EN(A,D)4X24*17** OMV098J12A FEM4P18**A* EN(A,D)4X18*14** *8MX* ** EN(A,D)4X24*17** FEM4P24**A* EN(A,D)4X18*14** ENH4X24*17** *8MPV FS(M,U)4P18**A* EN(A,D)4X19*17** *8MV* ** ENH4X24*17** *8MV* ** FS(M,U)4P24**A* EN(A,D)4X19*17** NOMV106D12* ENH4X24*17** *8MV* ** FXM4X18**A* EN(A,D)4X19*17** OLV098A12A ENH4X24*17** *8MX* ** FXM4X24**A* EN(A,D)4X19*17** OMV098J12A ENH4X24*17** *9MPV HC4A324 >ED*4X24B** EN(A,D)4X31*17** OMV112K14A ENH4X30*17** *9MVX EHD4X24A** *8MV* ** EN(A,D)4X31*17** ENH4X30*17** *9MVX EHD4X24A** *8MV* ** ENH4X24*17** *8MPV ENH4X30*17** MV08B15**B* EHD4X24A** *8MV* ** ENH4X24*17** *8MPV ENH4X30*17** MV12F19**B* EHD4X24A** *8MV* ** ENH4X24*17** *8MPV ENH4X30*17** NOMV106D12* EHD4X24A** *8MX* ** ENH4X24*17** *8MPV ENH4X30*17** OLV098A12A EHD4X24A** NOMV106D12* ENH4X24*17** *8MV* ** ENH4X30*17** OMV098J12A EHD4X24A** OLV098A12A ENH4X24*17** *8MV* ** ENH4X30*17** OMV112K14A EHD4X24A** OMV098J12A ENH4X24*17** *8MV* ** ENH4X30*17** EHD4X24A** OMV112K14A ENH4X24*17** *8MV* ** ENH4X31*17** *8MPV EHD4X30A** *8MV* ** ENH4X24*17** *8MX* ** ENH4X31*17** *8MPV EHD4X30A** *8MV* ** ENH4X24*17** *9MPV ENH4X31*17** *8MPV EHD4X30A** *8MV* ** ENH4X24*17** *9MPV ENH4X31*17** *8MPV EHD4X30A** *8MV* ** ENH4X24*17** *9MPV ENH4X31*17** *8MV* ** EHD4X30A** *8MX* ** ENH4X24*17** *9MPV ENH4X31*17** *8MV* ** EHD4X30A** NOMV106D12* ENH4X24*17** *9MVX ENH4X31*17** *8MV* ** EHD4X30A** OLV098A12A ENH4X24*17** *9MVX ENH4X31*17** *8MV* ** EHD4X30A** OMV098J12A ENH4X24*17** *9MVX ENH4X31*17** *8MX* ** EHD4X30A** OMV112K14A ENH4X24*17** *9MVX ENH4X31*17** *9MPV EN(A,D)4X24*14** *8MV* ** ENH4X24*17** MV08B15**B* ENH4X31*17** *9MPV EN(A,D)4X24*14** *8MX* ** ENH4X24*17** MV12F19**B* ENH4X31*17** *9MPV > Indicates Tested - continued on next page -

11 COOLING Multiplying Factors for other Indoor Combinations (continued) EN(A,D)4X24*14** ENH4X24*17** NOMV106D12* ENH4X31*17** *9MPV EN(A,D)4X24*17** *8MV* ** ENH4X24*17** OLV098A12A ENH4X31*17** *9MVX EN(A,D)4X24*17** NOMV106D12* ENH4X24*17** OMV098J12A ENH4X31*17** *9MVX EN(A,D)4X24*17** OLV098A12A ENH4X24*17** OMV112K14A ENH4X31*17** *9MVX EN(A,D)4X24*17** OMV098J12A ENH4X24*17** ENH4X31*17** *9MVX EN(A,D)4X24*17** OMV112K14A ENH4X30*17** *8MPV ENH4X31*17** MV08B15**B* EN(A,D)4X24*17** ENH4X30*17** *8MPV ENH4X31*17** MV12F19**B* EN(A,D)4X30*14** *8MV* ** ENH4X30*17** *8MPV ENH4X31*17** NOMV106D12* EN(A,D)4X30*14** *8MX* ** ENH4X30*17** *8MPV ENH4X31*17** OLV098A12A EN(A,D)4X30*14** ENH4X30*17** *8MV* ** ENH4X31*17** OMV098J12A EN(A,D)4X30*17** *8MV* ** ENH4X30*17** *8MV* ** ENH4X31*17** OMV112K14A EN(A,D)4X30*17** NOMV106D12* ENH4X30*17** *8MV* ** ENH4X31*17** EN(A,D)4X30*17** OLV098A12A ENH4X30*17** *8MV* ** FEM4P24**A* EN(A,D)4X30*17** OMV098J12A ENH4X30*17** *8MX* ** FEM4P30**A* EN(A,D)4X30*17** OMV112K14A ENH4X30*17** *9MPV FS(M,U)4P24**A* EN(A,D)4X30*17** ENH4X30*17** *9MPV FS(M,U)4P30**A* EN(A,D)4X31*17** *8MV* ** ENH4X30*17** *9MPV FXM4X24**A* EN(A,D)4X31*17** NOMV106D12* ENH4X30*17** *9MPV FXM4X30**A* EN(A,D)4X31*17** OLV098A12A ENH4X30*17** *9MVX EN(A,D)4X31*17** OMV098J12A ENH4X30*17** *9MVX HC4A330 >ED*4X30B** EN(A,D,W)4X36*17** OLV098A12A ENH4X31*17** *9MVX EHD4X30A** *8MV* ** EN(A,D,W)4X36*17** OMV098J12A ENH4X31*17** *9MVX EHD4X30A** *8MV* ** EN(A,D,W)4X36*17** OMV112K14A ENH4X31*17** *9MVX EHD4X30A** *8MV* ** EN(A,D,W)4X36*17** ENH4X31*17** MV08B15**B* EHD4X30A** *8MV* ** ENH4X30*17** *8MPV ENH4X31*17** MV12F19**B* EHD4X30A** *8MX* ** ENH4X30*17** *8MPV ENH4X31*17** NOMV106D12* EHD4X30A** *8MX* ** ENH4X30*17** *8MPV ENH4X31*17** OLV098A12A EHD4X30A** NOMV106D12* ENH4X30*17** *8MPV ENH4X31*17** OLV112A16A EHD4X36A** *8MV* ** ENH4X30*17** *8MV* ** ENH4X31*17** OMV098J12A EHD4X36A** *8MV* ** ENH4X30*17** *8MV* ** ENH4X31*17** OMV112K14A EHD4X36A** *8MV* ** ENH4X30*17** *8MV* ** ENH4X31*17** EHD4X36A** *8MV* ** ENH4X30*17** *8MV* ** ENH4X36*17** *8MPV EHD4X36A** *8MX* ** ENH4X30*17** *8MX* ** ENH4X36*17** *8MPV EHD4X36A** *8MX* ** ENH4X30*17** *8MX* ** ENH4X36*17** *8MPV EHD4X36A** NOMV106D12* ENH4X30*17** *9MPV ENH4X36*17** *8MPV EN(A,D)4X30*14** *8MV* ** ENH4X30*17** *9MPV ENH4X36*17** *8MV* ** > Indicates Tested - continued on next page -

12 COOLING Multiplying Factors for other Indoor Combinations (continued) EN(A,D)4X30*14** ENH4X30*17** *9MPV ENH4X36*17** *8MV* ** EN(A,D)4X30*17** *8MV* ** ENH4X30*17** *9MPV ENH4X36*17** *8MV* ** EN(A,D)4X30*17** *8MX* ** ENH4X30*17** *9MVX ENH4X36*17** *8MV* ** EN(A,D)4X30*17** NOMV106D12* ENH4X30*17** *9MVX ENH4X36*17** *8MX* ** EN(A,D)4X30*17** OLV098A12A ENH4X30*17** *9MVX ENH4X36*17** *8MX* ** EN(A,D)4X30*17** OMV098J12A ENH4X30*17** *9MVX ENH4X36*17** *9MPV EN(A,D)4X30*17** OMV112K14A ENH4X30*17** MV08B15**B* ENH4X36*17** *9MPV EN(A,D)4X30*17** ENH4X30*17** MV12F19**B* ENH4X36*17** *9MPV EN(A,D)4X31*17** *8MV* ** ENH4X30*17** NOMV106D12* ENH4X36*17** *9MPV EN(A,D)4X31*17** *8MX* ** ENH4X30*17** OLV098A12A ENH4X36*17** *9MVX EN(A,D)4X31*17** NOMV106D12* ENH4X30*17** OLV112A16A ENH4X36*17** *9MVX EN(A,D)4X31*17** OLV098A12A ENH4X30*17** OMV098J12A ENH4X36*17** *9MVX EN(A,D)4X31*17** OMV098J12A ENH4X30*17** OMV112K14A ENH4X36*17** *9MVX EN(A,D)4X31*17** OMV112K14A ENH4X30*17** ENH4X36*17** MV08B15**B* EN(A,D)4X31*17** ENH4X31*17** *8MPV ENH4X36*17** MV12F19**B* EN(A,D)4X36*21** *8MV* ** ENH4X31*17** *8MPV ENH4X36*17** NOMV106D12* EN(A,D)4X36*21** *8MX* ** ENH4X31*17** *8MPV ENH4X36*17** OLV098A12A EN(A,D)4X36*21** OLV112A16A ENH4X31*17** *8MPV ENH4X36*17** OLV112A16A EN(A,D)4X36*21** ENH4X31*17** *8MV* ** ENH4X36*17** OMV098J12A EN(A,D)4X37*17** *8MV* ** ENH4X31*17** *8MV* ** ENH4X36*17** OMV112K14A EN(A,D)4X37*17** *8MX* ** ENH4X31*17** *8MV* ** ENH4X36*17** EN(A,D)4X37*17** NOMV106D12* ENH4X31*17** *8MV* ** FEM4P30**A* EN(A,D)4X37*17** OLV098A12A ENH4X31*17** *8MX* ** FEM4P36**A* EN(A,D)4X37*17** OMV098J12A ENH4X31*17** *8MX* ** FS(M,U)4P30**A* EN(A,D)4X37*17** OMV112K14A ENH4X31*17** *9MPV FS(M,U)4P36**A* EN(A,D)4X37*17** ENH4X31*17** *9MPV FXM4X30**A* EN(A,D,W)4X36*17** *8MV* ** ENH4X31*17** *9MPV FXM4X36**A* EN(A,D,W)4X36*17** *8MX* ** ENH4X31*17** *9MPV EN(A,D,W)4X36*17** NOMV106D12* ENH4X31*17** *9MVX HC4A336 >ED*4X42J** END4X42*17** *8MX* ** ENH4X42*21** *9MVX ED*4X42L** *8MV* ** END4X42*17** NOMV106D12* ENH4X42*21** *9MVX EHD4X36A** *8MV* ** END4X42*17** OLV098A12A ENH4X42*21** *9MVX EHD4X36A** *8MV* ** END4X42*17** OMV098J12A ENH4X42*21** *9MVX EHD4X36A** *8MV* ** END4X42*17** OMV112K14A ENH4X42*21** MV08B15**B* EHD4X36A** *8MV* ** END4X42*17** ENH4X42*21** MV12F19**B* EHD4X36A** *8MX* ** ENH4X36*17** *8MPV ENH4X42*21** MV16J22**B* > Indicates Tested - continued on next page -

13 COOLING Multiplying Factors for other Indoor Combinations (continued) EHD4X36A** *8MX* ** ENH4X36*17** *8MPV ENH4X42*21** MV20L24**B* EHD4X36A** *8MX* ** ENH4X36*17** *8MPV ENH4X42*21** NOMV106D12* EHD4X36A** *8MX* ** ENH4X36*17** *8MPV ENH4X42*21** NOMV156E19* EHD4X36A** NOMV106D12* ENH4X36*17** *8MV* ** ENH4X42*21** OLV098A12A EHD4X36A** NOMV156E19* ENH4X36*17** *8MV* ** ENH4X42*21** OLV112A16A EHD4X42A** *8MV* ** ENH4X36*17** *8MV* ** ENH4X42*21** OLV154F20A EHD4X42A** *8MV* ** ENH4X36*17** *8MV* ** ENH4X42*21** OMV098J12A EHD4X42A** *8MV* ** ENH4X36*17** *8MX* ** ENH4X42*21** OMV112K14A EHD4X42A** *8MV* ** ENH4X36*17** *8MX* ** ENH4X42*21** EHD4X42A** *8MX* ** ENH4X36*17** *8MX* ** ENH4X43*21** *8MPV EHD4X42A** *8MX* ** ENH4X36*17** *8MX* ** ENH4X43*21** *8MPV EHD4X42A** *8MX* ** ENH4X36*17** *9MPV ENH4X43*21** *8MPV EHD4X42A** *8MX* ** ENH4X36*17** *9MPV ENH4X43*21** *8MPV EHD4X42A** NOMV106D12* ENH4X36*17** *9MPV ENH4X43*21** *8MV* ** EHD4X42A** NOMV156E19* ENH4X36*17** *9MPV ENH4X43*21** *8MV* ** EN(A,D)4X36*21** *8MV* ** ENH4X36*17** *9MVX ENH4X43*21** *8MV* ** EN(A,D)4X36*21** *8MX* ** ENH4X36*17** *9MVX ENH4X43*21** *8MV* ** EN(A,D)4X36*21** *8MX* ** ENH4X36*17** *9MVX ENH4X43*21** *8MX* ** EN(A,D)4X36*21** NOMV156E19* ENH4X36*17** *9MVX ENH4X43*21** *8MX* ** EN(A,D)4X36*21** OLV112A16A ENH4X36*17** MV08B15**B* ENH4X43*21** *8MX* ** EN(A,D)4X36*21** ENH4X36*17** MV12F19**B* ENH4X43*21** *8MX* ** EN(A,D)4X37*17** *8MV* ** ENH4X36*17** MV16J22**B* ENH4X43*21** *9MPV EN(A,D)4X37*17** *8MX* ** ENH4X36*17** MV20L24**B* ENH4X43*21** *9MPV EN(A,D)4X37*17** NOMV106D12* ENH4X36*17** NOMV106D12* ENH4X43*21** *9MPV EN(A,D)4X37*17** OLV098A12A ENH4X36*17** NOMV156E19* ENH4X43*21** *9MPV EN(A,D)4X37*17** OMV098J12A ENH4X36*17** OLV098A12A ENH4X43*21** *9MVX EN(A,D)4X37*17** OMV112K14A ENH4X36*17** OLV112A16A ENH4X43*21** *9MVX EN(A,D)4X37*17** ENH4X36*17** OLV154F20A ENH4X43*21** *9MVX EN(A,D)4X43*24** *8MV* ** ENH4X36*17** OMV098J12A ENH4X43*21** *9MVX EN(A,D)4X43*24** *9MPV ENH4X36*17** OMV112K14A ENH4X43*21** MV08B15**B* EN(A,D)4X43*24** *9MVX ENH4X36*17** ENH4X43*21** MV12F19**B* EN(A,D)4X43*24** MV20L24**B* ENH4X42*21** *8MPV ENH4X43*21** MV16J22**B* EN(A,D)4X43*24** ENH4X42*21** *8MPV ENH4X43*21** MV20L24**B* EN(A,D,W)4X36*17** *8MV* ** ENH4X42*21** *8MPV ENH4X43*21** NOMV106D12* EN(A,D,W)4X36*17** *8MX* ** ENH4X42*21** *8MPV ENH4X43*21** NOMV156E19* EN(A,D,W)4X36*17** NOMV106D12* ENH4X42*21** *8MV* ** ENH4X43*21** OLV098A12A EN(A,D,W)4X36*17** OLV098A12A ENH4X42*21** *8MV* ** ENH4X43*21** OLV112A16A > Indicates Tested - continued on next page -

14 COOLING Multiplying Factors for other Indoor Combinations (continued) EN(A,D,W)4X36*17** OMV098J12A ENH4X42*21** *8MV* ** ENH4X43*21** OLV154F20A EN(A,D,W)4X36*17** OMV112K14A ENH4X42*21** *8MV* ** ENH4X43*21** OMV098J12A EN(A,D,W)4X36*17** ENH4X42*21** *8MX* ** ENH4X43*21** OMV112K14A EN(A,D,W)4X42*21** *8MV* ** ENH4X42*21** *8MX* ** ENH4X43*21** EN(A,D,W)4X42*21** *8MX* ** ENH4X42*21** *8MX* ** FEM4P36**A* EN(A,D,W)4X42*21** *8MX* ** ENH4X42*21** *8MX* ** FEM4P42**A* EN(A,D,W)4X42*21** NOMV156E19* ENH4X42*21** *9MPV FS(M,U)4P36**A* EN(A,D,W)4X42*21** OLV112A16A ENH4X42*21** *9MPV FS(M,U)4P42**A* EN(A,D,W)4X42*21** ENH4X42*21** *9MPV FXM4X36**A* END4X42*17** *8MV* ** ENH4X42*21** *9MPV FXM4X42**A* HC4A348 >ED*4X48J** EN(A,D,W)4X48*21** NOMV156E19* ENH4X60*24** *8MX* ** ED*4X48L** *8MV* ** EN(A,D,W)4X48*21** OLV112A16A ENH4X60*24** *9MPV ED*4X48L** *8MX* ** EN(A,D,W)4X48*21** ENH4X60*24** *9MPV ED*4X60L** *8MV* ** EN(A,D,W)4X60*24** *8MV* ** ENH4X60*24** *9MVX ED*4X60L** *8MX* ** EN(A,D,W)4X60*24** *8MX* ** ENH4X60*24** *9MVX EHD4X48A** *8MV* ** EN(A,D,W)4X60*24** *9MPV ENH4X60*24** MV16J22**B* EHD4X48A** *8MV* ** EN(A,D,W)4X60*24** *9MVX ENH4X60*24** MV20L24**B* EHD4X48A** *8MV* ** EN(A,D,W)4X60*24** MV20L24**B* ENH4X60*24** NOMV156E19* EHD4X48A** *8MX* ** EN(A,D,W)4X60*24** ENH4X60*24** OLV112A16A EHD4X48A** *8MX* ** ENH4X48*21** *8MPV ENH4X60*24** OLV154F20A EHD4X48A** *8MX* ** ENH4X48*21** *8MPV ENH4X60*24** EHD4X48A** *8MX* ** ENH4X48*21** *8MV* ** ENH4X61*24** *8MPV EHD4X48A** NOMV156E19* ENH4X48*21** *8MV* ** ENH4X61*24** *8MPV EHD4X60A** *8MV* ** ENH4X48*21** *8MV* ** ENH4X61*24** *8MV* ** EHD4X60A** *8MV* ** ENH4X48*21** *8MX* ** ENH4X61*24** *8MV* ** EHD4X60A** *8MV* ** ENH4X48*21** *8MX* ** ENH4X61*24** *8MV* ** EHD4X60A** *8MX* ** ENH4X48*21** *8MX* ** ENH4X61*24** *8MX* ** EHD4X60A** *8MX* ** ENH4X48*21** *8MX* ** ENH4X61*24** *8MX* ** EHD4X60A** *8MX* ** ENH4X48*21** *9MPV ENH4X61*24** *8MX* ** EHD4X60A** *8MX* ** ENH4X48*21** *9MPV ENH4X61*24** *8MX* ** EHD4X60A** NOMV156E19* ENH4X48*21** *9MVX ENH4X61*24** *9MPV EN(A,D)4X48*24** *8MV* ** ENH4X48*21** *9MVX ENH4X61*24** *9MPV EN(A,D)4X48*24** *8MX* ** ENH4X48*21** MV16J22**B* ENH4X61*24** *9MVX EN(A,D)4X48*24** *9MPV ENH4X48*21** MV20L24**B* ENH4X61*24** *9MVX EN(A,D)4X48*24** *9MVX ENH4X48*21** NOMV156E19* ENH4X61*24** MV16J22**B* EN(A,D)4X48*24** MV20L24**B* ENH4X48*21** OLV112A16A ENH4X61*24** MV20L24**B* > Indicates Tested - continued on next page -

15 COOLING Multiplying Factors for other Indoor Combinations (continued) EN(A,D)4X48*24** ENH4X48*21** OLV154F20A ENH4X61*24** NOMV156E19* EN(A,D)4X61*24** *8MV* ** ENH4X48*21** ENH4X61*24** OLV112A16A EN(A,D)4X61*24** *8MX* ** ENH4X60*24** *8MPV ENH4X61*24** OLV154F20A EN(A,D)4X61*24** *9MPV ENH4X60*24** *8MPV ENH4X61*24** EN(A,D)4X61*24** *9MVX ENH4X60*24** *8MV* ** FEM4P48**A* EN(A,D)4X61*24** MV20L24**B* ENH4X60*24** *8MV* ** FEM4X60**B* EN(A,D)4X61*24** ENH4X60*24** *8MV* ** FS(M,U)4P48**A* EN(A,D,W)4X48*21** *8MV* ** ENH4X60*24** *8MX* ** FS(M,U)4X60**A* EN(A,D,W)4X48*21** *8MX* ** ENH4X60*24** *8MX* ** FXM4X48**A* EN(A,D,W)4X48*21** *8MX* ** ENH4X60*24** *8MX* ** FXM4X60**A* HC4A360 >ED*4X60L** EN(A,D,W)4X60*24** *8MV* ** ENH4X60*24** ED*4X60L** *8MV* ** EN(A,D,W)4X60*24** *8MX* ** ENH4X61*24** *8MPV ED*4X60L** *8MX* ** EN(A,D,W)4X60*24** MV20L24**B* ENH4X61*24** *8MV* ** EHD4X60A** *8MV* ** EN(A,D,W)4X60*24** ENH4X61*24** *8MV* ** EHD4X60A** *8MV* ** ENH4X60*24** *8MPV ENH4X61*24** *8MX* ** EHD4X60A** *8MX* ** ENH4X60*24** *8MV* ** ENH4X61*24** *8MX* ** EHD4X60A** *8MX* ** ENH4X60*24** *8MV* ** ENH4X61*24** MV16J22**B* EN(A,D)4X61*24** *8MV* ** ENH4X60*24** *8MX* ** ENH4X61*24** MV20L24**B* EN(A,D)4X61*24** *8MX* ** ENH4X60*24** *8MX* ** ENH4X61*24** EN(A,D)4X61*24** MV20L24**B* ENH4X60*24** MV16J22**B* FEM4X60**B* EN(A,D)4X61*24** ENH4X60*24** MV20L24**B* FXM4X60**A* > Indicates Tested

16 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 NOTE: This illustration is for reference only. Your unit may differ in appearance or may not include all components shown. Please refer to Parts List for exact parts listing. 6 J L H G 35 Compressor foot 11 Basepan Leg 10 D HC4A

17 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 NOTE: This illustration is for reference only. Your unit may differ in appearance or may not include all components shown. Please refer to Parts List for exact parts listing. COMPONENTS IN TRUE LOCATION N P 9 24 HC4A

18 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 NOTE: This illustration is for reference only. Your unit may differ in appearance or may not include all components shown. Please refer to Parts List for exact parts listing. 3 A C F E R K T B 2 S M M HC4A

19 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 HC4A3**AKA PARTS LIST KEY NO. DESCRIPTION FAST PARTS NO. HC4A318AKA100 HC4A324AKA100 HC4A330AKA100 HC4A336AKA100 HC4A348AKA100 HC4A360AKA COMPRESSOR ZP16K5EPFV ZP21K5EPFV ZP25K5EPFV ZP29K5EPFV ZP42K5EPFV ZP51K5EPFV MOTOR CONDENSER FAN FAN BLADE CONTACTOR 25 AMP 24V AMP 24V CAPACITOR 370V 30+5 MFD V 40+5 MFD V 45+5 MFD V 70+5 MFD KIT REPLACEMENT COIL SERVICE VALVE SUCTION SERVICE VALVE LIQUID PLUG COMPRESSOR HARNESS PLUG COMPRESSOR HARNESS GROMMET COMPRESSOR BOLT COMPRESSOR MOUNTING SWITCH HIGH PRESSURE MOUNT MOTOR DRIER FILTER LUG GROUND HEATER CRANKCASE HEATER CRANKCASE SWITCH TEMP CC HTR )( CAP SERVICE 11/ )( CAP SERVICE 15/ )( CAP SERVICE 1 1/ )( CAP FLARE SEAL A COVER TOP A B DECK FAN B C GRILLE INLET C C C D GRILLE OUTLET continued on next page

20 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 HC4A3**AKA PARTS LIST (continued) KEY NO. DESCRIPTION FAST PARTS NO. HC4A318AKA100 HC4A324AKA100 HC4A330AKA100 HC4A336AKA100 HC4A348AKA100 HC4A360AKA100 D D D E COVER ACCESS F PANEL ACCESS F F F G PAN BASE G H LEG MOUNTING H J PARTITION J J J K PANEL ELECTRICAL K K K L PLATE SERVICE VALVE M PANEL BLOCK OFF M N BOX ELECTRICAL P STRAP CAPACITOR P R GROMMET S SUPPORT COIL S S S T CORNER PANEL LEFT T T T )( SCREW HEX 10AB 1/ )( PAINT TOUCH UP 1PT

21 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 HC4A3**AHA PARTS LIST KEY NO. DESCRIPTION FAST PARTS NO. HC4A336AHA100 HC4A348AHA100 HC4A360AHA COMPRESSOR ZP29K5ETF ZP42K5ETF ZP51K5ETFD MOTOR CONDENSER FAN FAN BLADE CONTACTOR 18 AMP 24V CAPACITOR 440V 5 MFD KIT REPLACEMENT COIL KIT REPLACEMENT COIL SERVICE VALVE SUCTION SERVICE VALVE SUCTION SERVICE VALVE LIQUID PLUG COMPRESSOR HARNESS GROMMET COMPRESSOR BOLT COMPRESSOR MOUNTING SWITCH HIGH PRESSURE MOUNT MOTOR DRIER FILTER LUG GROUND HEATER CRANKCASE HEATER CRANKCASE SWITCH TEMP CC HTR )( CAP SERVICE 11/ )( CAP SERVICE 15/ )( CAP SERVICE 1 1/ )( CAP FLARE SEAL A COVER TOP B DECK FAN C GRILLE INLET C GRILLE INLET D GRILLE OUTLET D GRILLE OUTLET E COVER ACCESS F PANEL ACCESS F PANEL ACCESS G PAN BASE H LEG MOUNTING J PARTITION J PARTITION K PANEL ELECTRICAL K PANEL ELECTRICAL L PLATE SERVICE VALVE M PANEL BLOCK OFF N BOX ELECTRICAL P STRAP CAPACITOR R GROMMET S SUPPORT COIL S SUPPORT COIL T CORNER PANEL LEFT T CORNER PANEL LEFT )( SCREW HEX 10AB 1/ )( PAINT TOUCH UP 1PT

22 TECHNICAL SUPPORT MANUAL Ducted Horizontal Air Conditioner: HC4A3 KEY NO. HC4A3**ALA PARTS LIST DESCRIPTION FAST PARTS NO. 01 COMPRESSOR ZP29K5ETFD ZP42K5ETFD ZP51K5ETFD MOTOR CONDENSER FAN FAN BLADE CONTACTOR 18 AMP 24V CAPACITOR 440V 5 MFD KIT REPLACEMENT COIL KIT REPLACEMENT COIL SERVICE VALVE SUCTION SERVICE VALVE SUCTION SERVICE VALVE LIQUID PLUG COMPRESSOR HARNESS GROMMET COMPRESSOR BOLT COMPRESSOR MOUNTING SWITCH HIGH PRESSURE MOUNT MOTOR DRIER FILTER LUG GROUND HEATER CRANKCASE HEATER CRANKCASE SWITCH TEMP CC HTR )( CAP SERVICE 11/ )( CAP SERVICE 15/ )( CAP SERVICE 1 1/ )( CAP FLARE SEAL A COVER TOP B DECK FAN C GRILLE INLET C GRILLE INLET D GRILLE OUTLET D GRILLE OUTLET E COVER ACCESS F PANEL ACCESS F PANEL ACCESS G PAN BASE H LEG MOUNTING J PARTITION J PARTITION K PANEL ELECTRICAL K PANEL ELECTRICAL L PLATE SERVICE VALVE M PANEL BLOCK OFF N BOX ELECTRICAL P STRAP CAPACITOR R GROMMET S SUPPORT COIL S SUPPORT COIL T CORNER PANEL LEFT T CORNER PANEL LEFT )( SCREW HEX 10AB 1/ )( PAINT TOUCH UP 1PT HC4A336ALA100 HC4A348ALA100 HC4A360ALA100 International Comfort Products, LLC Lewisburg, Tennessee 37091