Quick Reference Guide FB 7600 Reference Crd Error Types Disply Possile cuse Possile ction messge Brnch pipe error elevtor error locking the movement of the rnch pipe. Grese or dirt locking the movement of the rnch pipe. on elevtor when mchine is switched on. Switch mchine OFF nd ON. Remove cup. Clen cup ctcher nd cup slide res. Remove cup. not delivered or Use own cup No more cups. Dirt or grese locking cup slide. No cups in cup mgzine Lod cups in cup mgzine. Clen cup slide. Use own cup / lod cups in cup mgzine. storge error pile locked. Remove locking cup. trnsport error slide locked. Remove locking cup. Door open Door not closed properly. Close door properly. FB wste ucket full Wste ucket full Fresh rew wste ucket full. Fresh rew wste ucket sensor soiled. Wste ucket full. Wste ucket sensor soiled. Empty fresh rew wste ucket nd wipe dry sensor. Clen nd wipe dry sensor. Empty wste ucket nd wipe dry sensor. Clen nd wipe dry sensor. Temperture low The mchine hs een turned on recently. Wit until the wter is heted sufficiently (mximum minutes). Wter tnk overoil Overoil thermostt hs triggered. Press reset utton. 040 7554600 If it ws impossile to remedy the fult, or other type of disply messge is shown, plese contct the service.
Reference Crd Error Types (continued) Error Possile cuse Possile ction types No disply or mchine not operting Sensors in wste uckets re wet. No power. Empty uckets nd dry sensors. Check fuses/power cord. Description of the Mchine Components Cinet Cinet door No ingredient Lek in mixing system or Mixing system overflows Cnister empty. Cnister not correctly connected. Ingredient sticking to uger drive mechnism. Mixing funnels/hoses not correctly connected. Whipper sel leking or not instlled. Blockge in mixing funnels or dispensing tues. Refill cnister. Reinsert cnister correctly. Remove cnister, clen uger drive mechnism nd reinsert. Reinstll nd reconnect components. Replce whipper sel. Replce / clen locked prt/s. Upper dvertising pnel Door lock Operting module stnd Buckets filled with wter Wter dripping from hot wter hoses. Liquid hs een poured into mchine. Wter tnk nd vlves must e declcified / replced. Instruct customers not to pour liquids into mchine. Lower dvertising pnel Mchine does not shut down when uckets re full Foreign ody clogging sensors for uckets. Sensors not in uckets. Clen sensors. Reposition sensors correctly in uckets. Coffee cnister Ingredient cnisters Min switch mgzine Freshrew unit mlfunction Fresh rew unit not correctly ssemled. Ressemle fresh rew unit correctly. Brewer Under try Outlet hoses Poor flvour of drink Indequte quntity of drink Coins sticking Mchine dispenses free drinks Wrong ingredients. Fresh rew unit or dispensing system dirty. Ingredient residues clogging dispensing outlet system. Kink in outlet hose. Coin mechnism sticking Coin trck dirty, gresy or locked. lock function ctivted. Price set to 0.00. Price set to free vend. Use corrrect ingredients. Replce/clen components nd rinse thoroughly. Replce/clen clogged component/s. Instll hose of correct length. Press coin return utton. Clen coin trck. cf. mnul of supplier. Wit for 0 seconds. Set correct price. Switch off free vend. Outlet spout Mixing funnel Sensor, coffee wste ucket Distriutor hed Coffee wste ucket Overflow hose Sensor, wste ucket drop ring slide Drip guide sttion Relese lever, cup stnd Drip try Wste ucket 4 If it ws impossile to remedy the fult, or other type of disply messge is shown, plese contct the service center.
Deep Clening *) Regulr Clening *) Opening nd disconnecting Opening nd disconnecting Turn the door key clockwise in keyhole (). Lift the triggered door hndle (). The mchine is utomticlly switched off. mgzine nd product cnisters mgzine Push side the cup conveyors (). Press down locking ltch nd open door of cup mgzine (). Plce cups in the cup mgzine, strting with the center column (4). Close door of cup mgzine. Freshrew cnister Tke the coffee cnister y the hndle, lift nd tilt forwrd cnister (5). Lift up lid nd fill cnister with coffee (6). Put lid ck on nd tilt ck cnister. Instnt ingredient cnisters Close the outlet spouts (7) of the ingredient cnisters y pushing the outlet tues upwrds. Tke the cnisters y the hndles nd pull them forwrd (8). The lids re utomticlly triggered open Fill cnisters with ingredients. Push ck cnisters. Open the outlet spouts (9) of the ingredient cnisters y pushing the tues downwrds. Turn the door key clockwise in keyhole (). Lift the triggered door hndle (). The mchine is utomticlly switched off. mgzine nd product cnisters Lod cups () (see regulr clening). Fill coffee cnister with coffee () (see regulr clening). Close the outlet spouts (4) of the ingredient cnisters y pushing the outlet tues upwrds. Fill ingredient cnisters with ingredients (5) (see regulr clening). Leve the outlet spouts closed. 6 stnd Clen cup stnd (0) with clen dmp cloth. 8 4 6 Clening prts It is recommended to hve mixing funnel hoods, mixing units with whipper wheels nd seling rings, powder trps, distriutor hed with outlet tues nd hoses (incl. rewer hose), complete filter plte, rewing cylinder with plunger nd scrper s n exchnge kit (hygiene kit). Sok ll prts, which will e disssemled, t lest for 5 minutes in ucket with hot wter with clening gent*. 7 Before disssemling the rewer switch the min switch of the mchine off! (6) Filter Plte Remove the rewer outlet hose (7) from the distriutor hed. Press the lock (8) t the support ckwrds nd withdrw the filter plte holder with hose (8). Press out the seling ring (8d) nd the filter plte (8c) y mens of the ejector pin (8e). Disssemle the filter plte (9) nd clen it**), if required, descle the filter***). 8 7 Clening prts 0 c d e 4 9 9 *) *) 5 All prts to e clened regulr re designed in light lue colour. All prts of ction re supplied in green colour. 0 All prts to e deep clened re designed in light nd drk lue colour. All prts of ction re supplied in green colour. For **) clening nd ***)descling: refer to the HACCP guidelines. (see overlef) 5 (see overlef) 5 7
Menu Selection Deep Clening (continued) Regulr Clening (continued) 0 c d Brewing cylinder nd scrper Remove the rewing cylinder (0). Withdrw the plunger (d) downwrds from the rewing cylinder. Remove the scrper (c) nd clen it*. Filter plte nd rewing cylinder cn lso e clened in dish wsher if ville. Instnt ingredient mixers Remove nd clen under trys under ingredient cnisters (). Relocte under trys. Remove the mixing hoods (). Remove mixing units: Loosen locking ring y pressing relese lever () nti-clockwise, nd pull out mixing funnel leving the hoses ck on. Pull off the whipper wheels (4). Remove nd clen the powder trps (4). Distriutor hed Unclip the distriutor hed y pressing upwrds from elow (5). Disssemle the distriuter hed, hoses nd mixing funnels. Sok components in hot wter with clening gent. Clening the dispensing re Remove drip guide (6) y pulling it up nd out. Unclip cup ctcher unit with one hnd nd remove it with the other using the hole in the guiding plte for cup ctcher (7). Unclip nd remove cup slide with shutter (7). stnd nd drip try Pull up nd tke out drip try (8). Press relese lever of cup stnd with your left hnd nd pull up the cup stnd with your right hnd (9). Clen the re round the cup sttion on front side of door. 4 5 6 7 8 Dispensing re Clen drip guide nd cup slide with shutter with clen dmp cloth () Coffee wste ucket Lift the coffee wste ucket sensor nd tke out wste ucket (), remove nd replce plstic g from ucket. Lift out the coffee wste chute (). Wipe clen ucket shelf nd re ehind ucket. Wste ucket Lift the wste ucket sensor nd tke the wste ucket out of mchine (). Empty nd clen ucket. Clening inside nd outside Clen the sensors of the wste uckets with clen dmp cloth nd wipe dry. Clen the door nd housing inside nd outside, nd finlly the ottom with clen, dmp cloth. Replcing the clened prts Replce ll prts. Rinsing Hve n empty pot (min..5 l) redy to plce on the cup stnd Turn to the disply nd perform mchine rinse using the preselection uttons (4). - Press utton '' to enter [Rinse]-function. - Close door nd plce pot on cup stnd (5). - Press 'Sel' to strt the rinse function. Follow the informtion on disply. Repet the rinse procedure min. once more. Press the utton 'Esc' until the mchine leves progrmming mode. Remove nd empty the pot. Lst check Clen the mchine with clen dmp cloth on the outside (6). Perform test vend y pressing selection utton eg. coffee with milk nd sugr. 4 5 6 *Opertor Technicin ^ V Sel Esc (see overlef) 9 8 6
Deep Clening (continued) Wste uckets Remove nd clen coffee wste chute (0), remove nd replce plstic g in coffee wste ucket (0) (see regulr clening). Remove, empty nd clen wste ucket. Clening inside nd outside Clen the sensors of the wste uckets with clen, dmp cloth nd wipe dry. Clen the door nd housing inside nd outside, nd finlly the ottom with clen, dmp cloth. Flush ll prts, which hve een soking, thoroughly with clen nd wrm wter. Check tht no dirt or clening gent remins on the prts. Dry ll prts with dry cloth. 0 0 Mounting the clened prts Remount ll prts (s to scrper, see c) nd relocte cnisters. Open the outlet spouts () of the instnt ingredient cnisters y pushing the tues downwrds. Check tht the coffee wste ucket nd the wste ucket with sensors re well positioned. Rinsing nd lst check Switch the min switch of the mchine on (). Rinse mchine twice (see regulr clening). Clen outside of mchine (clen dmp cloth). Perform test vend y pressing selection utton eg. coffee with milk nd sugr. HACCP Guidelines (continued) Declcifying Depending on the hrdness of wter, the metl prts of the filter plte holder must e clened fter pprox. 000 drinks. Filing After opening, write the dte of opening on the pckge File the "est efore"-dte of the pckge used to fill the mchine. File completed clening record crds (4). File service nd mintennce reports. Trining Trin stff on HACCP guidelines (5). Keep the reference crds with the mchine. Implement the ctivities in the work schedules. For further questions plese contct your service representtive. 4 5 c 9
Clening Record Crd HACCP Guidelines Declrtion: This mchine hs een clened in complince with the clening instructions. Signture Dte Time Regulr clening Weeky clening Monthly mngement check Dte Signture Comment coffee Directives For correct opertion of the mchine, t lest the mentioned guidelines must e tken into considertion. The opertor is held responsile for the correct opertion. HACCP guidelines Hndling of coffee nd ingredients Ensure hygienic hndling: - wsh hnds, preferly with disinfectnt () - use hygienic gloves - fter clening, do not touch surfces of prts tht my come into contct with food - lwys use clen cloth when clening - keep the working re tidy. Check the pckge for integrity nd dmge (). Store the coffee nd ingredients dry, cool nd drk. Use the pckges within the recommended time period (see the "est efore"-dte on the pckge). Alwys use pckges ccording to the "first-infirst-out"-principle. Thoroughly close n opened pckge to keep the qulity nd preventing contmintion. Coffee nd ingredients should e stored seprted from clening products. The ingredient cnister should e clened occsionlly (see operting instructions). Do not fill more coffee or ingredients thn needed until the next clening. Clening the mchine Oserve the clening instructions. Clen the mchine preferly t the end of the dy After clening, dispense nd check drink (see "Lst check"). Fill in the clening record crd. When the disply indictes n error messge (), oserve the reference crd. Only use the recommended clening gents tht hve een pproved for the food industry (slightly disinfecting, preferly liquids, ts, possily grins. Avoid powders). Welcome!! KEEP THIS CARD WITH THE FB 7600 MACHINE (nd file when completed) (see overlef) 0
Quick Reference Guide FB 7600 Reference Crd Error Types Disply Possile cuse Possile ction messge Brnch pipe error elevtor error locking the movement of the rnch pipe. Grese or dirt locking the movement of the rnch pipe. on elevtor when mchine is switched on. Switch mchine OFF nd ON. Remove cup. Clen cup ctcher nd cup slide res. Remove cup. not delivered or Use own cup No more cups. Dirt or grese locking cup slide. No cups in cup mgzine Lod cups in cup mgzine. Clen cup slide. Use own cup / lod cups in cup mgzine. storge error pile locked. Remove locking cup. trnsport error slide locked. Remove locking cup. Door open Door not closed properly. Close door properly. FB wste ucket full Wste ucket full Fresh rew wste ucket full. Fresh rew wste ucket sensor soiled. Wste ucket full. Wste ucket sensor soiled. Empty fresh rew wste ucket nd wipe dry sensor. Clen nd wipe dry sensor. Empty wste ucket nd wipe dry sensor. Clen nd wipe dry sensor. Temperture low The mchine hs een turned on recently. Wit until the wter is heted sufficiently (mximum minutes). Wter tnk overoil Overoil thermostt hs triggered. Press reset utton. 040 7554600 If it ws impossile to remedy the fult, or other type of disply messge is shown, plese contct the service.
Reference Crd Error Types (continued) Error Possile cuse Possile ction types No disply or mchine not operting Sensors in wste uckets re wet. No power. Empty uckets nd dry sensors. Check fuses/power cord. Description of the Mchine Components Cinet Cinet door No ingredient Lek in mixing system or Mixing system overflows Cnister empty. Cnister not correctly connected. Ingredient sticking to uger drive mechnism. Mixing funnels/hoses not correctly connected. Whipper sel leking or not instlled. Blockge in mixing funnels or dispensing tues. Refill cnister. Reinsert cnister correctly. Remove cnister, clen uger drive mechnism nd reinsert. Reinstll nd reconnect components. Replce whipper sel. Replce / clen locked prt/s. Upper dvertising pnel Door lock Operting module stnd Buckets filled with wter Wter dripping from hot wter hoses. Liquid hs een poured into mchine. Wter tnk nd vlves must e declcified / replced. Instruct customers not to pour liquids into mchine. Lower dvertising pnel Mchine does not shut down when uckets re full Foreign ody clogging sensors for uckets. Sensors not in uckets. Clen sensors. Reposition sensors correctly in uckets. Coffee cnister Ingredient cnisters Min switch mgzine Freshrew unit mlfunction Fresh rew unit not correctly ssemled. Ressemle fresh rew unit correctly. Brewer Under try Outlet hoses Poor flvour of drink Indequte quntity of drink Coins sticking Mchine dispenses free drinks Wrong ingredients. Fresh rew unit or dispensing system dirty. Ingredient residues clogging dispensing outlet system. Kink in outlet hose. Coin mechnism sticking Coin trck dirty, gresy or locked. lock function ctivted. Price set to 0.00. Price set to free vend. Use corrrect ingredients. Replce/clen components nd rinse thoroughly. Replce/clen clogged component/s. Instll hose of correct length. Press coin return utton. Clen coin trck. cf. mnul of supplier. Wit for 0 seconds. Set correct price. Switch off free vend. Outlet spout Mixing funnel Sensor, coffee wste ucket Distriutor hed Coffee wste ucket Overflow hose Sensor, wste ucket drop ring slide Drip guide sttion Relese lever, cup stnd Drip try Wste ucket 4 If it ws impossile to remedy the fult, or other type of disply messge is shown, plese contct the service center.
Deep Clening *) Regulr Clening *) Opening nd disconnecting Opening nd disconnecting Turn the door key clockwise in keyhole (). Lift the triggered door hndle (). The mchine is utomticlly switched off. mgzine nd product cnisters mgzine Push side the cup conveyors (). Press down locking ltch nd open door of cup mgzine (). Plce cups in the cup mgzine, strting with the center column (4). Close door of cup mgzine. Freshrew cnister Tke the coffee cnister y the hndle, lift nd tilt forwrd cnister (5). Lift up lid nd fill cnister with coffee (6). Put lid ck on nd tilt ck cnister. Instnt ingredient cnisters Close the outlet spouts (7) of the ingredient cnisters y pushing the outlet tues upwrds. Tke the cnisters y the hndles nd pull them forwrd (8). The lids re utomticlly triggered open Fill cnisters with ingredients. Push ck cnisters. Open the outlet spouts (9) of the ingredient cnisters y pushing the tues downwrds. Turn the door key clockwise in keyhole (). Lift the triggered door hndle (). The mchine is utomticlly switched off. mgzine nd product cnisters Lod cups () (see regulr clening). Fill coffee cnister with coffee () (see regulr clening). Close the outlet spouts (4) of the ingredient cnisters y pushing the outlet tues upwrds. Fill ingredient cnisters with ingredients (5) (see regulr clening). Leve the outlet spouts closed. 6 stnd Clen cup stnd (0) with clen dmp cloth. 8 4 6 Clening prts It is recommended to hve mixing funnel hoods, mixing units with whipper wheels nd seling rings, powder trps, distriutor hed with outlet tues nd hoses (incl. rewer hose), complete filter plte, rewing cylinder with plunger nd scrper s n exchnge kit (hygiene kit). Sok ll prts, which will e disssemled, t lest for 5 minutes in ucket with hot wter with clening gent*. 7 Before disssemling the rewer switch the min switch of the mchine off! (6) Filter Plte Remove the rewer outlet hose (7) from the distriutor hed. Press the lock (8) t the support ckwrds nd withdrw the filter plte holder with hose (8). Press out the seling ring (8d) nd the filter plte (8c) y mens of the ejector pin (8e). Disssemle the filter plte (9) nd clen it**), if required, descle the filter***). 8 7 Clening prts 0 c d e 4 9 9 *) *) 5 All prts to e clened regulr re designed in light lue colour. All prts of ction re supplied in green colour. 0 All prts to e deep clened re designed in light nd drk lue colour. All prts of ction re supplied in green colour. For **) clening nd ***)descling: refer to the HACCP guidelines. (see overlef) 5 (see overlef) 5 7
Menu Selection Deep Clening (continued) Regulr Clening (continued) 0 c d Brewing cylinder nd scrper Remove the rewing cylinder (0). Withdrw the plunger (d) downwrds from the rewing cylinder. Remove the scrper (c) nd clen it*. Filter plte nd rewing cylinder cn lso e clened in dish wsher if ville. Instnt ingredient mixers Remove nd clen under trys under ingredient cnisters (). Relocte under trys. Remove the mixing hoods (). Remove mixing units: Loosen locking ring y pressing relese lever () nti-clockwise, nd pull out mixing funnel leving the hoses ck on. Pull off the whipper wheels (4). Remove nd clen the powder trps (4). Distriutor hed Unclip the distriutor hed y pressing upwrds from elow (5). Disssemle the distriuter hed, hoses nd mixing funnels. Sok components in hot wter with clening gent. Clening the dispensing re Remove drip guide (6) y pulling it up nd out. Unclip cup ctcher unit with one hnd nd remove it with the other using the hole in the guiding plte for cup ctcher (7). Unclip nd remove cup slide with shutter (7). stnd nd drip try Pull up nd tke out drip try (8). Press relese lever of cup stnd with your left hnd nd pull up the cup stnd with your right hnd (9). Clen the re round the cup sttion on front side of door. 4 5 6 7 8 Dispensing re Clen drip guide nd cup slide with shutter with clen dmp cloth () Coffee wste ucket Lift the coffee wste ucket sensor nd tke out wste ucket (), remove nd replce plstic g from ucket. Lift out the coffee wste chute (). Wipe clen ucket shelf nd re ehind ucket. Wste ucket Lift the wste ucket sensor nd tke the wste ucket out of mchine (). Empty nd clen ucket. Clening inside nd outside Clen the sensors of the wste uckets with clen dmp cloth nd wipe dry. Clen the door nd housing inside nd outside, nd finlly the ottom with clen, dmp cloth. Replcing the clened prts Replce ll prts. Rinsing Hve n empty pot (min..5 l) redy to plce on the cup stnd Turn to the disply nd perform mchine rinse using the preselection uttons (4). - Press utton '' to enter [Rinse]-function. - Close door nd plce pot on cup stnd (5). - Press 'Sel' to strt the rinse function. Follow the informtion on disply. Repet the rinse procedure min. once more. Press the utton 'Esc' until the mchine leves progrmming mode. Remove nd empty the pot. Lst check Clen the mchine with clen dmp cloth on the outside (6). Perform test vend y pressing selection utton eg. coffee with milk nd sugr. 4 5 6 *Opertor Technicin ^ V Sel Esc (see overlef) 9 8 6
Deep Clening (continued) Wste uckets Remove nd clen coffee wste chute (0), remove nd replce plstic g in coffee wste ucket (0) (see regulr clening). Remove, empty nd clen wste ucket. Clening inside nd outside Clen the sensors of the wste uckets with clen, dmp cloth nd wipe dry. Clen the door nd housing inside nd outside, nd finlly the ottom with clen, dmp cloth. Flush ll prts, which hve een soking, thoroughly with clen nd wrm wter. Check tht no dirt or clening gent remins on the prts. Dry ll prts with dry cloth. 0 0 Mounting the clened prts Remount ll prts (s to scrper, see c) nd relocte cnisters. Open the outlet spouts () of the instnt ingredient cnisters y pushing the tues downwrds. Check tht the coffee wste ucket nd the wste ucket with sensors re well positioned. Rinsing nd lst check Switch the min switch of the mchine on (). Rinse mchine twice (see regulr clening). Clen outside of mchine (clen dmp cloth). Perform test vend y pressing selection utton eg. coffee with milk nd sugr. HACCP Guidelines (continued) Declcifying Depending on the hrdness of wter, the metl prts of the filter plte holder must e clened fter pprox. 000 drinks. Filing After opening, write the dte of opening on the pckge File the "est efore"-dte of the pckge used to fill the mchine. File completed clening record crds (4). File service nd mintennce reports. Trining Trin stff on HACCP guidelines (5). Keep the reference crds with the mchine. Implement the ctivities in the work schedules. For further questions plese contct your service representtive. 4 5 c 9
Clening Record Crd HACCP Guidelines Declrtion: This mchine hs een clened in complince with the clening instructions. Signture Dte Time Regulr clening Weeky clening Monthly mngement check Dte Signture Comment coffee Directives For correct opertion of the mchine, t lest the mentioned guidelines must e tken into considertion. The opertor is held responsile for the correct opertion. HACCP guidelines Hndling of coffee nd ingredients Ensure hygienic hndling: - wsh hnds, preferly with disinfectnt () - use hygienic gloves - fter clening, do not touch surfces of prts tht my come into contct with food - lwys use clen cloth when clening - keep the working re tidy. Check the pckge for integrity nd dmge (). Store the coffee nd ingredients dry, cool nd drk. Use the pckges within the recommended time period (see the "est efore"-dte on the pckge). Alwys use pckges ccording to the "first-infirst-out"-principle. Thoroughly close n opened pckge to keep the qulity nd preventing contmintion. Coffee nd ingredients should e stored seprted from clening products. The ingredient cnister should e clened occsionlly (see operting instructions). Do not fill more coffee or ingredients thn needed until the next clening. Clening the mchine Oserve the clening instructions. Clen the mchine preferly t the end of the dy After clening, dispense nd check drink (see "Lst check"). Fill in the clening record crd. When the disply indictes n error messge (), oserve the reference crd. Only use the recommended clening gents tht hve een pproved for the food industry (slightly disinfecting, preferly liquids, ts, possily grins. Avoid powders). Welcome!! KEEP THIS CARD WITH THE FB 7600 MACHINE (nd file when completed) (see overlef) 0